Electrical Parts List - Sony HT-MT500 Service Manual

HT-MT500/MT501
BAR-AMP BTW
Note:
• Due to standardization, replacements in
the parts list may be different from the
parts specifi ed in the diagrams or the com-
ponents used on the set.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Items marked "*" are not stocked since
they are seldom required for routine ser-
vice. Some delay should be anticipated
when ordering these items.
• RESISTORS
All resistors are in ohms.
METAL: Metal-fi lm resistor.
METAL OXIDE: Metal oxide-fi lm resistor.
F: nonfl ammable
Ref. No. Part No. Description
A-2161-701-A BAR-AMP BOARD, COMPLETE (See Note 1, 2)
************************
7-685-646-71 SCREW +BVTP 3X8 TYPE2 IT-3
< CONNECTOR >
CN6010 1-564-321-00 PIN, CONNECTOR (3.96 mm PITCH) 2P
CN6011 1-564-320-00 PIN, CONNECTOR (3.96 mm PITCH) 2P
CN6013 1-815-460-31 CONNECTOR, FFC/FPC 26P
CN6014 1-779-992-11 PIN, CONNECTOR (PWB) 8P
CN6015 1-779-884-11 CONNECTOR 4P
< DIODE >
D6002 6-502-961-01 DIODE DA2J10100L
D6003 6-502-961-01 DIODE DA2J10100L
D6004 6-502-961-01 DIODE DA2J10100L
D6005 6-503-605-01 DIODE UDZVTE-172.0B
D6006 6-503-605-01 DIODE UDZVTE-172.0B
D6007 6-502-961-01 DIODE DA2J10100L
D6008 8-719-053-18 DIODE 1SR154-400TE-25
D6009 8-719-053-18 DIODE 1SR154-400TE-25
D6010 8-719-053-18 DIODE 1SR154-400TE-25
D6011 6-500-451-01 DIODE CMS04-TE12R
D6012 6-503-004-01 DIODE DZ2J027M0L
D6013 6-503-658-01 LED SIM-013ST (IR REPEATER)
< FUSE >
0 F6001 1-523-088-11 FUSE (5 A/250 V)
< FERRITE BEAD/JUMPER RESISTOR >
FB6001 1-481-464-11 BEAD, FERRITE (1608)
FB6002 1-469-555-21 INDUCTOR
FB6003 1-469-555-21 INDUCTOR
FB6004 1-469-555-21 INDUCTOR
FB6005 1-216-864-91 SHORT CHIP
FB6007 1-469-555-21 INDUCTOR
FB6011 1-216-295-91 SHORT CHIP
FB6012 1-216-295-91 SHORT CHIP
FB6013 1-481-253-21 FERRITE, EMI (SMD) (1005)
< IC >
IC6001 6-723-251-01 IC TAS5624ADDVR-S (See Note 1)
IC6008 6-707-617-01 IC R1154H001C-FE
IC6010 6-716-865-01 IC MM1431FNRE
IC6014 6-719-198-01 IC MM3411A33URE
Note 1: When the complete BAR-AMP board or IC6001 on the BAR-
AMP board is replaced, refer to "SPREADING OF COM-
POUND" on page 8.
62
SECTION 7

ELECTRICAL PARTS LIST

• CAPACITORS
uF: μF
• COILS
uH: μH
• SEMICONDUCTORS
In each case, u: μ, for example:
uA. . : μA. . , uPA. . , μPA. . ,
uPB. . : μPB. . , uPC. . , μPC. . ,
uPD. . : μPD. .
When indicating parts by reference num-
ber, please include the board name.
The components identifi ed by mark 0
or dotted line with mark 0 are critical for
safety.
Replace only with part number specifi ed.
Remark
* IC6015
10uH 0 TH3001
10uH
10uH
0
10uH
*************************************************************
0
0
*************************************************************
Note 2: When the complete BAR-AMP board is replaced, refer to
The components identifi ed by mark 9 con-
tain confi dential information.
Strictly follow the instructions whenever the
components are repaired and/or replaced.
Among mounted electrical parts on each
boards, only parts that are described in
the electrical parts list can be replaced for
repair.
The parts that are not described in the
electrical parts list cannot be replaced with
single for repairing.
Ref. No. Part No. Description
6-722-068-01 IC 74LCX541FT
< JACK >
J6001 1-844-230-11 UNIFIED POLARITY TYPE DC JACK
J6002 1-843-401-21 JACK, STEREO (MINI TYPE) (ANALOG IN)
< JUMPER RESISTOR >
JC6001 1-216-864-91 SHORT CHIP
JC6002 1-216-864-91 SHORT CHIP
JC6005 1-216-864-91 SHORT CHIP
JC6011 1-216-864-91 SHORT CHIP
< TRANSISTOR >
Q6004 6-550-585-01 TRANSISTOR
Q6005 8-729-013-22 TRANSISTOR
Q6006 6-553-239-01 TRANSISTOR
Q6007 8-729-200-72 TRANSISTOR
Q6008 8-729-200-72 TRANSISTOR
Q6009 8-729-200-72 TRANSISTOR
Q6010 6-553-624-01 TRANSISTOR
Q6011 8-729-232-69 FET
Q6012 8-729-200-72 TRANSISTOR
Q6013 8-729-216-22 TRANSISTOR
Q6014 8-729-013-28 TRANSISTOR
< COMPOSITION CIRCUIT BLOCK >
RB6001 1-234-381-11 RES, NETWORK 100K (1005X4)
< THERMISTOR >
1-804-045-11 THERMISTOR
< VIBRATOR >
X3001 1-814-852-11 OSCILLATOR, CRYSTAL (49.152 MHz)
BTW BOARD
**********
J2401 1-821-559-11 CONNECTOR, COAXIAL (SMT TYPE)
"BOND FIXED POSITION OF ELECTRICAL PARTS" on
page 8.
Remark
(19.5V )
0
0
0
0
2PC4081R-115
HN1A01FU
TTC3710B, S4X (S
2SC2712L-TE85L
2SC2712L-TE85L
2SC2712L-TE85L
2SA2097
2SK208-GR3
2SC2712L-TE85L
2SA1162-G
HN1B01FU