Operation; Selection And Qualification Of Operating Personnel; Operating Safety Instructions - Delta CP.0.DPS Series Operation Manual

6. Operation

6.1 Selection and qualification of operating personnel

For independent operation or maintenance of
the following requirements:
At least 18 years of age.
CAUTION
Mentally and physically capable.
WARNING
WARNING
Have been instructed in the operation or maintenance of the
winch and have proven their qualification in this aspect(In addition to
theoretical training, instruction should also include sufficient practical operating
experience as well as acquisition of ability to identify defects which are hazards
to safe operation).
WARNING Can be expected to carry out the work assigned to them reliably. The person in
charge must assign operating and maintenance personnel to their relevant tasks.

6.2 Operating safety instructions

CAUTION
The
operators.
Always wear the necessary protective gear.
WARNING
The operators should not engage in any other practice which will divert his
WARNING
attention while actually engaged in operating the winch.
If unsafe conditions exist, the operator should have the authority to refuse to
CAUTION
handle any loads until safety has been reassured.
DANGER Always use structures and additional pulling - lifting equipment that has the
correct safe working load and make sure that a generous safety factor is
included.
Always make sure that the load does not exceed the rated capacity.
DANGER
For points fitted with warning alarm, it should be sounded each time before use
DANGER
/ travelling; and intermittently during travel particularly when operator or other
personnel is approached. If not, the user is responsible to inform everyone when
winch is operated.
DANGER Always check the winch, steel wire and hook prior to use, it needs to be in good
condition. Otherwise put the winch out of service and inform your dealer.
Before leaving a winch unattended, the operator should release the tension or
WARNING
lower any goods. It may never be left under tension.
At the start of each shift, the operator should check the operation of each mode
CAUTION
pulling and releasing.
All loads should be securely hitched and properly balanced before a pull/lift is
DANGER
made.
Winch and wire rope should be continually inspected for wear or any other kind
DANGER
of damage that could make them unsafe to work with.
WARNING The wire rope must be in a straight line from the load hook to the suspension
point before the pull/lift is performed.
Pulling, lifting people or riding on the hook, slings or load is dangerous and
DANGER
strictly prohibited
When pulling or lifting, ensure that the load does not have any obstructions.
WARNING
Loads should not pass over the heads of personnel or in any way. This is strictly
DANGER
prohibited, while it endangers the safety.
Never apply side pull.
WARNING
electric puling winch, the operator must meet
winch should be operated only by designated and trained
electric
14