Electronic Systems / Battery - Bat-caddy X4 Series User Manual

Electronic Systems
• Remote Control Range: We recommend not to exceed 20-30 yards distance. The greater
the distance between you and the caddy, the greater the chance of losing control of it.
• Microcomputer: The remote caddy has 3 microcomputer controls. The primary
microprocessor is in its own compartment underneath the battery tray. We call it the
controller. The 2nd is in the remote control transmitter handset, and the third is in handle
controls at the top of the handle (handle control board). The battery charge indicator lights
will light up indicating the power is "ON". Also, it will indicate the charge level of the battery,
green ( OK to run) or red (near discharged, will fail shortly)
• Safety Protection: When the temperature of the controller box reaches its upper limit, the
overload circuit will automatically shut down the unit to cool it down. The remote control
unit will NOT operate at this time, but you may continue to use your caddy with manual
operation.
• Microprocessor Controlled Electronics System: When you connect the battery, the
electronics system will automatically run through a start-up routine; then once completed
you can press the main OFF/ON switch on the handle. The battery charge indicator lights
will show you the charge level of the battery from green (fully charged) to red (discharged).
• Important: The electronics controller box contains no user serviceable parts.
Therefore, it is sealed to reduce the risk of moisture entering and impacting the
electronic system. Breaking this seal increases the risk of damaging the electronics and
decreasing the reliability of your caddy. DO NOT attempt to open the controller case.
DOING SO WILL VOID THE WARRANTY!
• Battery Operation and Care: Follow battery charge and maintenance instructions. The
battery comes with leads and a 3-prong connector.
Battery Maintenance and Additional Instructions
• Battery Charging and Maintenance (see specific separate instructions for sealed lead
acid (SLA) and lithium batteries)
• PLEASE OBEY THESE PRECAUTIONS FOR BATTERY USE & CHARGING:
• Please do not charge the battery in a sealed container or in upside down position. Charge
the battery in a well-ventilated area.
• Please do not charge the battery near a heat source, where heat accumulation may occur,
or in direct sunlight.
• In order to prolong the service life of the battery, avoid complete discharge and charge the
battery after every use. Unplug the battery from the charger once the charge is complete.
When the caddy is not in use for an extended period of time, it is recommended to charge
the battery once every 6 weeks.
• The red color on the battery pole stands for positive, and the black stands for negative. In
case of battery replacement, please reconnect the poles of the battery correctly to avoid
severe damage.
• Please do not disassemble the battery or throw it into a fire. EXPLOSION HAZARD!
• NEVER TOUCH THE ELECTRIC POLES OF THE BATTERY AT THE SAME TIME! THIS
IS A SEVERE SAFETY HAZARD!
11