Emissions Control System Warranty - Mack Granite GU Series Operator's Handbook Manual

18 INTRODUCTION
THIS WARRANTY IS EXPRESSLY IN LIEU OF ALL OTHER WARRANTIES
AND REPRESENTATIONS OR CONDITIONS, STATUTORY OR
OTHERWISE, EXPRESSED OR IMPLIED INCLUDING, BUT NOT LIMITED
TO, IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A
PARTICULAR PURPOSE.

Emissions Control System Warranty

The following engine components are covered by the supplemental emissions control
system warranty policy as required by the California code of regulations.
1 Turbocharger Assembly
•
VGT Actuator
2 Charge Air Cooler
•
CAC Pipes (Air inlet to/from CAC)
•
CAC Hoses
3 Engine Control Module (ECM)
4 Injectors
5 Engine and Vehicle Wire harness (
repair to circuits related to Emissions
Warrantable Components )
6 Exhaust Gas Recirculation (EGR)
Mixer
7 EGR Cooler
8 EGR Valve and EGR Valve Control
9 EGR Pipes - Engine Exhaust Manifold
to EGR Cooler
10 EGR Pipes - EGR Cooler to Inlet
Manifold
11 Crankcase Breather
12 Crankcase Separator
13 Crankcase Tubing and Hoses before
Separator
14 Aftertreatment Wiring Harness
15 After treatment Control Module (ACM)
16 Aftertreatment Diesel Particulate Filter
(DPF) Assembly
A. Aftertreatment DPF Assembly
with Aftertreatment Diesel Oxidation
Catalyst (DOC)
•
Aftertreatment Doser
•
Diffuser Pipe (Aftertreatment Fuel
Doser Mounting)
•
Fuel lines to Aftertreatment Fuel
Doser
•
Aftertreatment Fuel Shutoff Valve
•
Aftertreatment Fuel Pressure Sensor
•
Engine Turbocharger Compressor
Bypass Actuator (Heat Mode)
•
Engine Turbocharger Compressor
Bypass Actuator Solenoid
•
Engine Exhaust Gas Temperature
(EGT) Sensor
•
Aftertreatment DPF Intake
Temperature Sensor
•
Aftertreatment DPF Outlet
Temperature Sensor
•
Aftertreatment DPF Differential
Pressure Sensor
•
Aftertreament Doser Air Supply
Regulator (if applicable), Supply
Lines, and Fittings
B. Thermal Regeneration Unit (TRU)
•
Aftertreatment DPF Air Shutoff
Valve
•
Aftertreatment DPF Combustion
Air Valve
•
Aftertreatment DPF Atomization
Module
•
Aftertreatment DPF Ignition Coil