Air Cleaner/Intake; Air Cleaner; Breather Tube; Air Cooling - Kohler HD Series Service Manual

Air Cleaner/Intake

AIR CLEANER

These systems are CARB/EPA certifi ed and components
should not be altered or modifi ed in any way.
Air Cleaner Components
D
A Air Cleaner Cover
C Paper Element
E Air Cleaner Knob
NOTE: Operating engine with loose or damaged air
cleaner components could cause premature
wear and failure. Replace all bent or damaged
components.
NOTE: Paper element cannot be blown out with
compressed air.
Loosen knob and remove air cleaner cover.
Precleaner (if equipped)
1. Remove precleaner.
2. Replace or wash precleaner in warm water with
detergent. Rinse and allow to air dry.
3. Reinstall precleaner into cover, aligning hole in
precleaner with upper cover knob.
Paper Element
1. Remove paper element from base and replace.
2. Install element with pleated side out and seat rubber
seal onto edges of base.
Reinstall air cleaner cover and secure with knob.
20
C
B
A
E
B Precleaner
D Base
KohlerEngines.com

BREATHER TUBE

Make sure both ends of breather tube are properly
connected.

AIR COOLING

Hot Parts can cause severe burns.
Do not touch engine while operating or just
after stopping.
Never operate engine with heat shields or guards
removed.
Proper cooling is essential. To prevent over heating,
clean screens, cooling fi ns, and other external surfaces
of engine. Avoid spraying water at wiring harness or any
electrical components. Refer to Maintenance Schedule.
WARNING
14 690 10 Rev. --