Towing - Volvo G700B Series Operator's Manual

Operating instructions

Towing

WARNING!
Improper towing methods or equipment could result in
severe personal injury or death. Read and understand the
towing instructions and precautions in this manual.
WARNING!
If the engine cannot be started, the brake and steering
functions will be limited. In this case, towing should be
restricted to emergencies only and over the shortest
possible distance by knowledgeable personnel. If
possible, transport the machine on a trailer.
General
The operator must be in the operator's seat to control steering
n
and braking when towing the grader.
Do not tow the grader with the engine shut down. Braking and
n
steering capabilities are reduced with the engine shut down.
To release the parking brake manually, refer to Manual re-
n
lease of parking brake page 106.
If the engine runs, ensure the transmission shift lever is in
n
NEUTRAL. Tow the grader with the engine running. On All
Wheel Drive models, make sure the All Wheel Drive system is
switched OFF.
Some state and local laws prohibit or limit the use of tow
n
chains on highways. Check state and local regulations.
If the final drive is damaged, do not tow the grader. Do not at-
n
tempt to start the engine by towing. Damage to the transmis-
sion will result.
Provide adequate shielding for the operator against towline
n
breakage.
Do not tow the grader faster than 8 km/h (5 mph).
n
Be sure the vehicle which does the towing is at least as heavy
n
as the machine being towed. This will ensure sufficient engine
and braking capabilities to be able to pull and stop both ma-
chines on any uphill or downhill slope.
If the towed grader cannot be braked, a tow bar or two towing
n
machines must be used – one in front pulling and one at the
rear to provide braking. Do not tow over long distances.
Ensure the towline or bar is in good condition and is strong
n
enough for the towing situation. Mark the center of the towline
with a flag or brightly colored cloth. Ensure that a 'slow moving
vehicle sign' is attached to the rear of the grader.
Ensure the towline angle is less than 20 degrees with respect
n
to the horizontal plane.
Do not allow the towline to contact any components mounted
n
on the grader.
Towing 101