Replacing The Fuel Filter; Electrical System Maintenance; Servicing The Battery - Toro TRX-16 Operator's Manual

Replacing the Fuel Filter

Service Interval: Every 200 hours
Never install a dirty filter if it is removed from the fuel
line.
Note:
Note how the fuel filter is installed in order to
install the new filter correctly.
Note:
Wipe up any spilled fuel.
1. Park the machine on a level surface, engage the
parking brake, and lower the hydraulic lift.
2. Shut off the engine and remove the key.
3. Turn the fuel shutoff valve to the closed position
(Figure 38).
4. Squeeze the ends of the hose clamps together
and slide them away from the filter
Figure 39
1. Hose clamp
2. Fuel line
5. Remove the filter from the fuel lines.
6. Install a new filter and move the hose clamps
close to the filter.
7. Turn the fuel shutoff valve to the open position
(Figure 38).
8. Check for fuel leaks and repair if needed.
9. Wipe up any spilled fuel.
(Figure 39).
g001468
3. Filter
Electrical System
Maintenance

Servicing the Battery

Electric-Start Machines Only
Service Interval: Every 25 hours—Check the battery
electrolyte level.
Always keep the battery clean and fully charged. Use
a paper towel to clean the battery case. If the battery
terminals are corroded, clean them with a solution of
4 parts water and 1 part baking soda. Apply a light
coating of grease to the battery terminals to reduce
corrosion.
Voltage: 12 V with 300 A (cold cranking) at -18°C
(0°F).
CALIFORNIA
Proposition 65 Warning
Battery posts, terminals, and related
accessories contain lead and lead
compounds, chemicals known to
the State of California to cause
cancer and reproductive harm. Wash
hands after handling.
WARNING
Incorrect battery cable routing could damage
the machine and cables, causing sparks.
Sparks can cause the battery gasses to
explode, resulting in personal injury.
• Always disconnect the negative (black)
cable before disconnecting the positive
(red) cable.
• Always connect the positive (red) cable
before connecting the negative (black)
cable.
31
WARNING