Table of Contents
Advertisement
E Schaudt GmbH, Elektrotechnik und Apparatebau, Planckstraße 8, 88677 Markdorf, Germany, Tel. +49 7544 9577-0, Fax +49 7544 9577-29, www.schaudt- -gmbh.de
9110476 BA / EN
Operating Instructions
Electroblock
Table of contents
1
1.1
1.2
1.3
2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
3
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
3.1
3.2
3.3
3.4
4
4.1
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4.2
4.3
5
5.1
5.2
6
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
EBL 211
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2
2
2
3
3
4
4
5
6
7
9
9
10
10
11
11
11
12
13
Date: 22.01.2016
Advertisement
Table of Contents
Related Manuals for Schaudt Electroblock EBL 211
Summary of Contents for Schaudt Electroblock EBL 211
-
Page 1: Table Of Contents
..........E Schaudt GmbH, Elektrotechnik und Apparatebau, Planckstraße 8, 88677 Markdorf, Germany, Tel. +49 7544 9577-0, Fax +49 7544 9577-29, www.schaudt- -gmbh.de 9110476 BA / EN Date: 22.01.2016... -
Page 2: Safety Information
Operating Instructions Electroblock EBL 211 Safety information Meaning of safety symbols DANGER! Failure to comply with this sign may result in danger to life or physical con- dition. WARNING! Failure to comply with this sign may result in injury. ATTENTION! Failure to comply with the sign may result in damage to equipment or other connected loads. -
Page 3: Liability Limitation
Introduction This instruction manual contains important information for the safe operation of equipment supplied by Schaudt. Make sure you read and follow the safety instructions provided. The operating instructions should always be kept in the vehicle. All safety in- formation must be passed on to other users. -
Page 4: Operation
Operating Instructions Electroblock EBL 211 Operation The electroblock is operated solely from the operator and control panel con- nected (apart from battery isolation). Operation of the electroblock is not required for daily use. Settings only have to be configured when the battery type is changed (AGM or lead-gel), during initial start-up or when retrofitting accessories (refer to Section 3.2 and the installation instructions EBL 211). -
Page 5: Changing The Battery
Operating Instructions Electroblock EBL 211 Changing the battery ATTENTION! Use of incorrect battery types or incorrectly rated batteries. Damage to the battery or devices connected to the electroblock: Batteries may only be changed by qualified personnel. Follow the battery manufacturer’s instructions. -
Page 6: Operating Faults
If this is not possible, such as when you are abroad, a specialist workshop will be able to repair the device. In this case, you must ensure that the war- ranty is not invalidated by incorrect repairs being carried out. Schaudt GmbH will not accept any liability for damage resulting from such repairs. -
Page 7: Shutting Down
Operating Instructions Electroblock EBL 211 Fault Possible cause Remedy Solar charger does not Solar panel in (partial) Move solar panel out of work (power supply and shade or covered (snow or shade or clean it. engine are off) dirt) Solar charge regulator not... - Page 8 Operating Instructions Electroblock EBL 211 Fully charge the leisure area battery before closing down the system. " Switch off the 12V main switch on the control panel. " Move battery cut-out switch (switch, see Fig. 4, Pos. 5) to position ”Bat- "...
-
Page 9: Application And Functions In Detail
Operating Instructions Electroblock EBL 211 Application and functions in detail General This device is intended solely for installation in a vehicle. The electroblock is the central energy supply device for all 12 V consumers in the electrical system on board the motorhome/caravan. It is normally loca- ted inside a cupboard or storage area and is accessible from the front for fuse changes. -
Page 10: Battery Functions
Operating Instructions Electroblock EBL 211 Battery functions Suitable batteries 6-cell AGM or lead-gel batteries, 55 Ah and above Battery cut-out The battery cut-out (at the battery cut-out switch of the electroblock, see Fig. 4, Pos. 15, see also Section 3.4) isolates the following connections from the... -
Page 11: Technical Details
Operating Instructions Electroblock EBL 211 Mains charging This feature provides an automatic float charge for the starter battery at up starter battery to 2 A when the 230 V mains is connected to the electroblock. Technical details Mechanical details Dimensions... -
Page 12: Maintenance
Operating Instructions Electroblock EBL 211 Battery charging of the Starter battery starter battery Charge current trickle charge max. 2 A Charging voltage typ. U -- 0,2 V Wbat IUoU curve New charge cycle, for battery voltage < 13.7 V switchover to main charging with approx. -
Page 13: Appendix
Schaudt DT ..., LT ... or IT ... control panel (required for operation) Solar charge regulator Schaudt solar charge regulator, type LR ... , LRS ... or LRM ... for solar mo- dules with a total charge current of 14 A with 3-pin connector (charging of... - Page 14 Operating Instructions Electroblock EBL 211 Layout Fig. 4 Layout of the EBL 211 electroblock (front) Connector for control panel Mains connection Battery switchover (types gel / AGM) Housing Flat vehicle fuse for AES refrigerator Connection block, solar regulator (supply) Flat vehicle fuses for consumers 6.3 mm consumer connectors...
- Page 15 Operating Instructions Electroblock EBL 211 Block diagram/wiring diagram * The negative terminals for leisure area and starter batteries must be connected to each other externally. LAS 1218 Changeover switch Battery on / off Lead-gel Battery cut- -out switch: Isolates the control panel and the frost protection valve of the heater system from the battery to prevent standby currents during shut- -down.
- Page 16 Operating Instructions Electroblock EBL 211 (Blank page) Date: 22.01.2016 9110476 BA / EN...