Vanair Reliant RS45 Installation, Operation, Maintenance And Parts Manual page 54

SECTION 7: ILLUSTRATED PARTS LIST
TABLE 7A: RECOMMENDED SPARE PARTS LIST
KEY NO. VANAIR PART NUMBER
1 KIT1285
2 KIT1095
3
IV
4
IV
5 264626-1GAL
6 264469
7 264470
8 264471
9
V
10 275558
11 260246
12 277764
13
VI
®
Use only Vanair Vanguard™ Premium Synthetic Oil and Genuine Vanair Parts. Substituting non-Vanguard oil or non-genuine Vanair filter components WILL VOID THE COMPRES-
I
SOR WARRANTY! Inspect and replace damaged components before operation. Compressor system fill capacity is approximately four (4) quarts of oil.
Compressor initial 50 hours maintenance kit consists of: one [1] gallons of Vanair Vanguard Compressor Oil, no. 264626-1GAL, and a compressor oil filter no. 264471.
II
500 hour maintenance kit consists of: one [1] gallons of Vanair Vanguard Compressor Oil, no. 264626-1GAL, compressor oil filter no. 264471, air filter no. 264469, and separator filter
III
no. 264470.
For component replacement details consult the Vanair Service Department.
IV
For hose replacement(s) refer to the hose and tube assembly sub-sections (Sections 7.9 and 7.10, respectively) to obtain replacement hose part order numbers.
V
Replacement fuses can sometimes be found at local vendor carriers, such as automobile supply stores, hardware stores, etc.
VI
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE MACHINE SERIAL NUMBER (see Figure 7-1).
The above table listing contains items that require maintenance on a routine basis, and
also those parts that may require maintenance over the course of the compressor
package's performance schedule. Although this recommended list is pro-offered as a
comprehensive guide to replacement parts, damage may occur to the machine beyond
Should any part of the compressor package that is not listed in Table 7A become
damaged or inoperable, use the various sub-sections in Section 7 to best locate and
identify the damaged part(s).
PAGE - 46
FULL SERVICE MAINTENANCE KITS
Kit, Compressor Service - Initial 50 Hours
Kit, Compressor Service - 500 Hours
Kit, Compressor Shaft Seal Replacement
Option, (Kit for) Cold Weather
INDIVIDUAL MAINTENANCE ITEMS
Oil, Vanair Vanguard™ Compressor (gallon)
Element, Replacement for Compressor Air Filter
Element, Replacement for Compressor Separator
Element, Replacement for Compressor Oil Filter
Hoses, Replacement
Breaker, Circuit with Studs (40A)
Relay, NO/NC Weatherproof with Resistor
Coupling, Spider Drive Replacement
Fuse, 10A
IMPORTANT
the scope of this listing.
090126-OP_r0 (JAN-2018)
DESCRIPTION
I & II
I & III
If additional spare parts are being stored for future use,
ensure that they are stored in proper containers that allow for
protection against contamination, and kept in a clean area of
moderate temperature reading. For information on storing the
machine package for periods of non-use, consult Section
5.4.8, Storage and Intermittent Use.
RELIANT RS45 AIR COMPRESSOR
QUANTITY
IMPORTANT
VANAIR MANUFACTURING, INC.
(844) VAN-SERV • www.vanair.com
1
1
1
1
1
1
1
1
-
1
1
1
2