Trouble Shooting - Hayter Motif 41 Push Owner's Handbook Manual

TROUBLE SHOOTING

PROBLEM CAUSES
Engine will not turn
Engine stop lever released
over
Incorrect oil level
Obstruction under deck
Engine smokes Excess oil
Air cleaner cartridge oil soaked or
blocked
Engine runs then stops Fuel starvation
Fuel cap vent blocked
Engine will not start Engine under load
Incorrect / contaminated fuel
Spark plug lead disconnected
Engine brake not released
Faulty spark plug
Wiring fault
Engine runs rough
Spark plug lead becoming
disconnected in use
Faulty spark plug
Air cleaner blocked
Incorrect / contaminated fuel
CORRECTIVE ACTION PROBLEM
Engine vibrates
Operate engine stop lever
excessively
Check oil level
Remove obstruction
Check oil level
Uneven cut
Service air cleaner
Fill fuel tank / Turn fuel shutoff
valve to the 'ON' position
Clean fuel cap vent
Discharge chute blocks
Raise the height of cut
Drain tank and fi ll with correct
fuel
Connect spark plug lead
Mower is hard to push
Operate engine brake lever
Clean and adjust the gap or
Mower will not self
replace
propel
Check wiring
Poor grass condition
Connect spark plug lead
Clean and adjust gap or replace
Service air cleaner
Cutterblade drive will
Drain tank and fi ll with correct
not engage/disengage
fuel
17
CAUSES CORRECTIVE ACTION
Mounting bolt loose Tighten bolt
Cutterblade bolt loose Tighten bolt
Cutterblade out of balance Balance cutterblade
Bent crankshaft Consult your dealer
Undulating ground conditions Change direction of travel
Cutterblade worn Sharpen cutterblade
Cutterblade out of balance Balance the cutterblade
Wheels/roller damaged Inspect and replace as necessary
Grass is wet Mow dry grass
Cut height too low Increase cut height
Grassbag full Empty grassbag
No airfl ow through the grassbag Clean the grassbag
Cut height too low Increase cut height
Wheels/roller damaged Inspect and replace as necessary
Drive belt damaged Replace drive belt
No airfl ow through the grassbag Clean the grassbag
Discharge chute blocked Remove blockage
Wet grass Mow dry grass
Grassbag full Empty grassbag
Engine stop lever not fully Push fully forward to disengage
forward