Operation - MULTIQUIP MVC-90H Operation And Parts Manual

Operation

CAUTION - General Operation Safety
Make sure to follow all safety rules referenced in the safety
section of this manual before operating compactor. Keep
work area clear of debris and other objects that could cause
damage to the compactor or bodily injury.
1. Once the engine has started, move the engine throttle
lever quickly to the FAST position. With the throttle lever
in the fast position, the engine speed should be around
2,300 RPM, which engages the centrifugal clutch.
Always move the throttle lever
quickly without hesitation.
NOTE
Increasing the engine speed
slowly causes the clutch to slip
and can damage your clutch.
2. Firmly gasp the compactor's handle bar with both hands
as the compactor begins moving forward.
3. Slowly walk behind the compactor and be on the lookout
for any large objects or foreign matter that might cause
damage to the compactor or bodily injury.
Whenever the compactor's vibra-
tion becomes weak or lost during
NOTE
normal operation regardless of op-
eration hours, check the V-belt
and clutch immediately.
MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)— PAGE 21
MVC-90H PLATE COMPACTOR — OPERATION
Operating the Compactor on High Moisture Content Soil
Compactor traveling speed may drop on soils which contain
clay, or other types of soil. Soil with high moisture content can
cause the compaction plate to "stick" to the ground (not lifting
up off the ground very fast or high).
To rectify this problem, consider the following:
 Check the bottom plate to see if clay or equivalent
material has been lodged in the plate mechanism. If so,
wash with water and remove.
 Remember the compactor does not work as efficiently
on clay or soils that have a high moisture content level.
 If the soil has a high moisture level, dry soil to
appropriate moisture content level or carry out
compaction twice.
Using the Compactor Sprinkler System
The MVC-90H is equipped with a watering system that can
be used to wet the ground during compaction to keep dust
levels down.
To operate the watering system, turn the water cock handle
to open the valve (Figure 18) and start the water flow. With the
compactor at full speed and the water cock fully open, the
water system will provide approximately 20 minutes of
sprinkling.
Figure 18. Water System