Page 1
OPERATION AND PARTS MANUAL SERIES MODEL MVC-90H ONE-WAY PLATE COMPACTOR (HONDA GASOLINE ENGINE) Revision #3 (01/10/11) www.discount-equipment.com THIS MANUAL MUST ACCOMPANY THE EQUIPMENT AT ALL TIMES.
Page 2
One of our experienced staff members will get back to you with a quote for the right part that your machine needs. We sell worldwide for the brands: Genie, Terex, JLG, MultiQuip, Mayco, Toro/Stone, Diamond Products, Magnum, Airman, Mustang, Power Blanket, Nifty Lift, Atlas Copco,...
Gasket Kit Assembly ......... 74-75 Label Assembly ..........76-77 Terms and Conditions Of Sale — Parts ....78 Specification and part number NOTE are subject to change without notice. PAGE 4 — MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)
COULD result in DEATH or SERIOUS INJURY. CAUTION Indicates a hazardous situation which, if not avoided, COULD result in MINOR or MODERATE INJURY. NOTICE Addresses practices not related to personal injury. PAGE 6 — MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)
ALWAYS clear the work area of any debris, tools, etc. that would constitute a hazard while the equipment is in operation. MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)— PAGE 7...
Page 7
PAGE 8 — MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)
Page 8
ALWAYS keep battery cables in good working condition. hot engine. Repair or replace all worn cables. MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)— PAGE 9...
Page 9
DO NOT use food or plastic containers to dispose of hazardous waste. DO NOT pour waste, oil or fuel directly onto the ground, down a drain or into any water source. PAGE 10 — MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)
The double-V belt drive assures less downtine and superior drive characteristics. Unit can still operate if one belt breaks. PAGE 14 — MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)
If the V-belt cover is not installed, the possibility exist that your hand may get caught between the V- belt and clutch, thus causing serious injury and bodily harm. MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)— PAGE 15...
5. Fuel Valve Lever – OPEN to let fuel flow, CLOSE to stop the flow of fuel. 10. Fuel Tank – Holds unleaded gasoline. For additional information refer to engine owner's manual. PAGE 16 — MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)
NOTE mixture for starting a COLD engine. The OPEN position provides the correct fuel mixture for normal operation after starting, and for restarting a warm engine. MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)— PAGE 19...
Figure 16. Engine ON/Off Switch (OFF Position) 3. Place the fuel valve lever (Figure 17) in the OFF position. Figure 17. Fuel Valve Lever (OFF Position) PAGE 20 — MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)
Whenever the compactor's vibra- tion becomes weak or lost during NOTE normal operation regardless of op- eration hours, check the V-belt and clutch immediately. Figure 18. Water System MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)— PAGE 21...
Fuel piping and connections should NOTE t i w s i h i h c l l a g i r be replaced every 2 years. PAGE 22 — MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)
(Figure 19), 2. Tip the compactor to drain the oil. Vibrator oil will drain more easily NOTE while it is warm. MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)— PAGE 23...
Page 22
5. Place the V-belt on the lower vibrator pulley. Push the V- belt to the left side of the upper clutch and rotate the offset wrench clockwise so that the V-belt moves onto the pulley. PAGE 24 — MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)
Page 23
Clean entire plate compactor, especially the bottom plate removing all dirt and foreign matter. Cover plate compactor and engine with plastic covering or equivalent and store in a clean, dry place. MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)— PAGE 25...
MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)— PAGE 27...
Page 26
. d r r o t r t n , c i r o t c o l ) s t PAGE 28 — MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)
Page 27
Multiquip. Other entries will for sale through Multiquip. be clarified in the “Remarks” Column. PAGE 30 — MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)
POWERED BY AN ELECTRIC MOTOR, DISCONNECT ELECTRICAL PLUG. NEVER LEAVE MACHINE UNATTENDED WHEN OPERATING. ALWAYS STOP ENGINE AND ALLOW ENGINE TO COOL BEFORE ADDING FUEL OR OIL. NPA-329 PAGE 32 — MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)
Page 46
JET, MAIN (#68) OPTIONAL 99101ZH80700 JET, MAIN (#70) 99204ZE00350 JET, SET, PILOT (#35) NOTICE GX160K1QMX2: Model MVC-90H S/N N-5696 AND BELOW GX160U1QMX2: Model MVC-90H S/N N-5697 AND ABOVE MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)— PAGE 49...
Page 47
HONDA GX160K1QMX2/GX160U1QMX2 ENG. — CONTROL ASSY. PAGE 50 — MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)
Page 48
NUT, SELF-LOCK (6MM) 93500050250H SCREW, PAN (5 X 25) 90605230000 CIRCLIP 93500040060H SCREW, PAN (5 X 25) 93500050160A SCREW, PAN (5 X 16) 9405006000 NUT, FLANGE (6MM) MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)— PAGE 51...
Page 52
WASHER, 8 MM ..........1....S/N 6745959 AND ABOVE 90473842000 WASHER, 8 MM 90745ZE1600 KEY, 78 X 38 MM NOTICE GX160K1QMX2: Model MVC-90H S/N N-5696 AND BELOW GX160U1QMX2: Model MVC-90H S/N N-5697 AND ABOVE MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)— PAGE 55...
Page 74
MARK, OIL ALERT (E) 87532ZH7000 MARK, THROTTLE INDICATION 87516ZH7000 MARK, OPERATOR CAUTION ENGLISH NOTICE GX160K1QMX2: Model MVC-90H S/N N-5696 AND BELOW GX160U1QMX2: Model MVC-90H S/N N-5697 AND ABOVE MVC-90H PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (01/10/11)— PAGE 77...
Page 75
One of our experienced staff members will get back to you with a quote for the right part that your machine needs. We sell worldwide for the brands: Genie, Terex, JLG, MultiQuip, Mayco, Toro/Stone, Diamond Products, Magnum, Airman, Mustang, Power Blanket, Nifty Lift, Atlas Copco,...