Page 1
It can also make consumers aware of actions that are unpredictable and unsafe. The NOTICE label indicates special instructions that are important but not related to hazards. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: 908.351.5400...
Mechanical Entrapment- There is potential for jewelry, swimsuit, hair decorations, finger, toe or knuckle to be caught in an opening of a suction outlet or suction outlet cover resulting in mechanical entrapment. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: 908.351.5400...
Page 3
Inches of Mercury (in Hg) - A unit for measuring pressure below atmospheric (“suction” or “vacuum”) (1.0 inch Hg = .491 PSI) Main Drain – See Suction Outlet PSI – An abbreviation for pounds per square inch. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: 908.351.5400...
General Information: The VR1000 Vacuum Release System is designed as a pump controller. The system will protect pool and spa equipment from certain mechanical failures, such as clogged drains and pipe breakage; which can cause premature pump motor failure. The system monitors and recognizes a change in pressure and electrical power.
Page 5
P/N: ISVR1000 Rev: M FIG 3 Internal Control External FIG 2 FIG 5 FIG 4 Internal Control FIG 7 FIG 6 THREE PHASE PUMP MOTOR SUGGESTED CONNECTION USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: 908.351.5400 www.haywardpool.com...
Page 6
DATE? Y/N needs to be replaced.) If “YES” follow screen instructions SET TIMER EVENTS is the only used when the VR1000 has been set to allow SET TIMER control of pump on/off times.(or with use of a 2-speed pump) See Page 8 for screen EVENTS Y/N information.
Page 7
“OK” button to restart the system. • If the VR1000 has shut the pump down due to “HIGH VACUUM” and does not restart, due to debris in the suction line, the line must be cleared. This is normally done through the use of a garden hose or other method.
Page 8
For the Booster pump timer “ON” time equals “OFF” time the pump will always be “OFF” 7 DAY MODE ON = 04:00 AM “YES” will use the timing events currently stored in the VR1000 OFF=08:00 PM OK? “NO” will allow setting the timers Blinking time indicates that the timer is ready to be set.
Page 9
“stop” switch(s); or else the audible alarm(s) will be silenced automatically after 10 minutes. However manual intervention, including responding to certain questions via the LCD display and function pushbuttons, is required in order to restart the system. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: 908.351.5400...
Vent Filter ¼” NPTM (Pack includes 8’ hose & fittings to extend hose above water level) CLX220J25 5/16” Tubing x 25’ Long (See Fig 6) VRXPCBA Printed Circuit Board USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: 908.351.5400 www.haywardpool.com...
Page 11
(except gas piping), and conduit within 5 ft. (1.5 m) of inside walls of swimming pool, spa, or hot tub. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: 908.351.5400...
– Wait five (5) seconds before re-starting pump. Failure to do so may cause reverse rotation of motor and consequent serious pump damage. Close air relief valve after pump is primed. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: 908.351.5400...
That is, changing the pattern of flow from the suction outlet (Main Drain) to the skimmer will simulate an entrapment. Periodic testing of the VR1000 can be performed by pushing the “OK” button. This will verify •...
Page 14
To obtain warranty replacements or repair, defective components or parts should be returned, transportation paid, to the place of purchase, or to the nearest authorized Hayward service center. For further Hayward dealer or service center information, contact Hayward customer service department. No returns may be made directly to the factory...
DETACH HERE: REGISTER ONLINE AT WWW.HAYWARDNET.COM Fill out completely and mail within 10 days of purchase/installation, or --------------------------------------------------------------------------------------------------------- Mail to: Hayward Pool Products, 620 Division Street, Elizabeth, NJ 07207, Attn: Warranty Dept. Warranty Registration Card Please Print Clearly: Name__________________________________________________ Purchased Date:________________________________________________...
Page 16
Page 16 of 16 STRATUM™ Model VR1000 P/N: ISVR1000 Rev: M THIS PAGE IS BLANK USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: 908.351.5400 www.haywardpool.com...