Table of Contents
Advertisement
Specifications
Engine . . . . . . . . . . . . . . . . . .
Cylinders (number) . . . . . . . . . . . . . .
Displacement . . . . . . . . . . . . . . . . . .
Firing order . . . . . . . . . . . . . . . . . . . .
Bore and stroke . . . . . . . . . . . . . . . . .
Full throttle operating range . . . . . . .
Idle RPM . . . . . . . . . . . . . . . . . . . . . .
Fuel System
GXi-A . . . . . . . . . . . . . . . . . . . . . . . .
GXi-B . . . . . . . . . . . . . . . . . . . . . . . .
Fuel pumps . . . . . . . . . . . . . . . . . . . .
Fuel filter . . . . . . . . . . . . . . . . . . . . . .
Fuel filter location . . . . . . . . . . . . . . .
Fuel type . . . . . . . . . . . . . . . . . . . . . .
Electrical System
Charging system . . . . . . . . . . . . . . . .
Battery size . . . . . . . . . . . . . . . . . . . .
Starter . . . . . . . . . . . . . . . . . . . . . . . .
Ignition System
Distributor . . . . . . . . . . . . . . . . . . . . .
Ignition timing . . . . . . . . . . . . . . . . . .
Spark plugs . . . . . . . . . . . . . . . . . . . .
Spark plug gap . . . . . . . . . . . . . . . . .
Spark plug installation torque . . . . . .
Cooling system
Raw water pump . . . . . . . . . . . . . . . .
Recirculating pump . . . . . . . . . . . . . .
Thermostat . . . . . . . . . . . . . . . . . . . .
GXi-BF . . . . . . . . . . . . . . . . . . . . . . .
Thermostat . . . . . . . . . . . . . . . . . . . .
Oil capacity
Engine without filter . . . . . . . . . . . . .
Engine with filter . . . . . . . . . . . . . . . .
Drive unit SX . . . . . . . . . . . . . . . . . . .
Drive unit DP-S . . . . . . . . . . . . . . . . .
Engine Oil filter . . . . . . . . . . . . . . . . .
Oil filter location . . . . . . . . . . . . . . . .
Oil type
Engine . . . . . . . . . . . . . . . . . . . . . . . .
Drive unit . . . . . . . . . . . . . . . . . . . . . .
Power steering fluid U.S. . . . . . . . . .
Power steering fluid non-U.S. . . . . . .
94
4.3GXi-A, 4.3GXi-B(F)
90° V-6
262 cubic inches (4.3 liters)
1 – 6 – 5 – 4 – 3 – 2
4.000 x 3.480 in. (101.60 x 88.39 mm)
4200 – 4600 RPM
600 RPM
Throttle body injection
Port injection
Electric
Volvo Penta P/N 3852413
Refer to photographs on features pages.
Inside the U.S.: 89 octane (AKI) unleaded gasoline
Outside the U.S.: 93 octane (RON) unleaded gasoline
12 volt 65 amp alternator, with internal transistorized voltage regulator
12 volt with 650 Cold Cranking Amp (CCA) rating (135 minute reserve capacity)
CAUTION! Do not use a deep cycle battery as the start battery.
12 volt 1.7kW output, planetary reduction gear
Delco EST
GXi-A: 8° BTDC service mode required
GXi-B: 10°BTDC service mode required
Volvo Penta Part no. 3861632
1.50 mm (0.060 inches)
27 N·m (20 ft. lb.)
Crankshaft mounted variable volume flexible impeller pump
Fixed impeller belt driven pump on engine
71°C (160°F) Volvo Penta part no. 3856961
Closed cooling heat exchanger mounted on engine.
76°C (170°F) Volvo Penta part no. 875788
3.8 liters (4 quarts)
4.3 liters (4.5 quarts)
2.1 liters (2.2 quarts)
2.4 liters (2.5 quarts)
Volvo Penta Part no. 841750
Refer to photographs on features pages.
DuraPlus™ Heavy Duty Synthetic engine oil, or suitable pure synthetic oil altenative
with the minimum API service raing SJ
DuraPlus SAE 75W/90 API service GL 5 synthetic gear oil
DuraPlus power steering fluid Part no. 3851039
ATF oil Dexron 2 Part no. 1161941
7741591 / 2003-12
Advertisement
Table of Contents
