Automatic Transmission Fluid - Mitsubishi PAJERO IV Service Manual

1-16
36. HOSES, FLUID LINES AND
CONNECTIONS LOCATED UNDER HOOD
CAUTION
Remember that the air conditioner system is
under pressure.
1. Check all brake, fuel, power steering and air
conditioner lines and connections; verify proper
routing, check connections for leaks, tighten loose
connector as required.
2. Inspect routing and connections of all vacuum,
and radiator and heater houses.
NOTE: Keep in mind that an oily residue around
an air conditioner connector does not necessarily
indicate a leak. Oil is used to lubricate fittings dur-
ing assembly. Be sure lines are not twisted or
kinked.
37. MANUAL TRANSMISSION AND
TRANSFER (4WD) OIL LEVEL
Transmission oil
1. Remove the filler plug.
2. Check the oil level. If the oil level is at or slightly
below the filler hole, it is in satisfactory condition.
3. If the level is low, replenish the transmission and
transfer case with fresh oil by using a lubricator.
NOTE: For the specified oil, refer to GROUP 2,
Periodic Inspection and Maintenance.
PRE-DELIVERY INSPECTION
AFTER ROAD TEST

38. AUTOMATIC TRANSMISSION FLUID

LEVEL
M6010900400203
1. Remove the dipstick and check the fluid level.
2. Fluid level is okay if it is in the specified range as
AC305643
3. If the level is below the lower notch, replenish fluid
39. ENGINE, TRANSMISSION, STEERING
GEAR BOX AND DIFFERENTIAL FOR
LEAKS
Check the engine, transmission, steering gear box
and differential for oil leaks.
40. FRONT AND REAR DIFFERENTIAL
M6010900500211
OIL LEVELS
1. Remove the filler plug.
2. Check the oil level. If the oil level is at or slightly
AC305644
AB
Type 1 only: Remove the filler plug, and check the
3. If the level is low, replenish the front and/or rear
illustration at normal engine operating
temperature.
until the level reaches the upper notch.
NOTE: For the specified automatic transmission
fluid, refer to GROUP 2, Periodic Inspection and
Maintenance.
below the filler hole, it is in satisfactory condition.
TYPE 1
8 mm
Upper
limit
Lower
limit
gear oil level. Check that gear oil level is not 8
mm below the bottom of filler plug hole.
differential with fresh oil by using a lubricator.
M6010900600230
AC005861AD
M6010900700055
M6010900800234
•
TYPE 2
Gear oil
AC305646 AC