Care Of Your Door Operator - Chamberlain ATS2113X 1/2 HP Installation Manual

Care of Your Operator
LIMIT AND FORCE ADJUSTMENTS:
Weather conditions may cause some
minor changes in door operation requiring
some re-adjustments, particularly during
the fi rst year of operation.
Pages 21 and 22 refer to the limit and
force adjustments. Only a screwdriver is
required. Follow the instructions carefully.
Repeat the safety reverse test (Adjustment Step 3,
page 23) after any adjustment of limits or force.
MAINTENANCE SCHEDULE
Every Month
• Manually operate door. If it is unbalanced or binding, call a
trained door systems technician.
• Check to be sure door opens and closes fully. Adjust limits
and/or force if necessary. (See pages 21 and 22.)
• Repeat the safety reverse test. Make any necessary
adjustments. (See Adjustment Step 3.)
Two Times a Year
• Check chain tension. Disconnect trolley fi rst. Adjust if
necessary. (See page 7.)
Every Year
• Oil door rollers, bearings and hinges. The operator does
not require additional lubrication. Do not grease the door
tracks.
Every Three to Four Years
• Use a rag to wipe away the existing grease from the door
operator rail. Reapply a small layer of white lithium grease
to the rail.
THE REMOTE CONTROL BATTERIES
FORCE CONTROLS
LIMIT CONTROLS
The Lithium battery should produce power for
up to 3 years.
To replace battery, use the visor
clip or screwdriver blade to pry
open the case as shown. Insert
battery positive side up (+).
Dispose of old battery properly.
Replace the battery with only
3V CR2032 coin cell batteries.
NOTICE: To comply with FCC and or Industry Canada (IC) rules,
adjustment or modifications of this receiver and/or transmitter are
prohibited, except for changing the code setting or replacing the
battery. THERE ARE NO OTHER USER SERVICEABLE PARTS.
Tested to Comply with FCC Standards FOR HOME OR OFFICE USE.
Operation is subject to the following two conditions: (1) this device may
not cause harmful interference, and (2) this device must accept any
interference received, including interference that may cause undesired
operation.
26
To prevent possible SERIOUS INJURY or DEATH:
• NEVER allow small children near batteries.
• If battery is swallowed, immediately notify doctor.
To reduce risk of fi re, explosion or chemical burn:
• Replace ONLY with 3V CR2032 coin batteries.
• DO NOT recharge, disassemble, heat above 100° C
(212° F) or incinerate.
Battery
positive
side up (+)