Subscribe to Our Youtube Channel
Related Manuals for Sure Flame S1505B
Summary of Contents for Sure Flame S1505B
- Page 1 S1505B CONSTRUCTION HEATER Rev. 4.32 Aug 29, 2014 SERVICE AND MAINTENANCE MANUAL No. 974-9308 PLEASE RETAIN FOR FUTURE REFERENCE PRODUCTS A DIVISION OF HAUL-ALL EQUIPMENT LTD. 4115 - 18 Ave. N, Lethbridge, Alberta www.sureflame.com...
- Page 2 WARNING Not for home or recreational vehicle use Page 2 S1505B Manual 974-9308 Rev. 4.32; Aug 29 2014...
- Page 3 THORITY IF YOU HAVE QUESTIONS ABOUT LOCAL REGU- LATIONS. Other standards govern the use of fuel gases and heat produc- ing products in specific applications. Your local authority can advise you about these. S1505B Manual 974-9308 Rev. 4.32; Aug 29 2014 Page 3...
-
Page 4: Table Of Contents
Safety Features On-Site Hazards Preventative Maintenance Troubleshooting Tables Replacement Parts Wiring Diagrams Two Stage Thermostat Wiring Diagram LPG - Propane Fuel Vaporization Rate Maximum BTU Content (Propane) Pressure & Flow Equivalents Page 4 S1505B Manual 974-9308 Rev. 4.32; Aug 29 2014... -
Page 5: Specifications
Inlet Pressure Manifold Pressure Max W.C. Min W.C. Max W.C. Min.W.C. Propane 14" 9" 2.7" 0.75" Natural 14" 9" 7.2" 2.0" (Minimum inlet pressure is for purpose of input adjustment) S1505B Manual 974-9308 Rev. 4.32; Aug 29 2014 Page 5... -
Page 6: Installation
Installation The Sure Flame Model S1505B is a direct fired gas heater intended to be used primarily for the temporary heating of buildings under construction, alteration, or repair. Since all the products of combustion are released into the area being heated, it is imperative that adequate ventilation is provided. -
Page 7: Installation Using A Propane Supply Cylinder
The installation of this heater to a natural gas supply must conform with all applicable local codes or, in the absence of local codes, with the National Fuel Gas Code ANSI Z223.1/NFPA 54. S1505B Manual 974-9308 Rev. 4.32; Aug 29 2014 Page 7... -
Page 8: Operating Instructions
Requirements for Temporary and Portable Space Heating Devices and Equipment Used in the Construction Industry. THE INSTALLATION AND MAINTENANCE OF THE HEATER MUST BE ACCOMPLISHED BY A QUALIFIED SERVICE PERSON. Page 8 S1505B Manual 974-9308 Rev. 4.32; Aug 29 2014... -
Page 9: Common Installation And Operational Problems
Safety Controls Servicing of Sure Flame Construction Heaters normally involves one of several built-in safety features. The Model S1505B incorporates devices to detect the following: 1 LOSS OF FLAME Gas supply is shut off if flame is lost to prevent raw gas from leaving the heater. -
Page 10: Safety Features
Sure Flame Heaters are designed to have a low skin temperature. This provides added safety in the workplace. DURABLE CONSTRUCTION The Model S1505B uses a stainless steel burner for long life and consistent performance. In order to maintain the highly efficient combustion of the Sure Flame Heater, the combustion chamber must remain as manufactured. -
Page 11: Preventive Maintenance
Preventive Maintenance Sure Flame Construction Heaters are built to withstand the rigours of operating on construction sites, mining applications, and a multitude of other locations where heaters are used. To maintain the reliable performance it is necessary to perform regular maintenance. -
Page 12: Troubleshooting Tables
Chart C – Heater does not start, fan starts, spark, no flame Chart D – Heater starts, flame lights but goes out after a few seconds Chart E – Heater starts, but fails during operation Chart F – Other problems Page 12 S1505B Manual 974-9308 Rev. 4.32; Aug 29 2014... - Page 13 S1505B Manual 974-9308 Rev. 4.32; Aug 29 2014 Page 13...
- Page 14 Page 14 S1505B Manual 974-9308 Rev. 4.32; Aug 29 2014...
- Page 15 S1505B Manual 974-9308 Rev. 4.32; Aug 29 2014 Page 15...
- Page 16 Page 16 S1505B Manual 974-9308 Rev. 4.32; Aug 29 2014...
- Page 17 S1505B Manual 974-9308 Rev. 4.32; Aug 29 2014 Page 17...
- Page 18 Page 18 S1505B Manual 974-9308 Rev. 4.32; Aug 29 2014...
- Page 19 S1505B Manual 974-9308 Rev. 4.32; Aug 29 2014 Page 19...
-
Page 20: Replacement Parts
Page 20 S1505B Manual 974-9308 Rev. 4.32; Aug 29 2014... - Page 21 S1505B Manual 974-9308 Rev. 4.32; Aug 29 2014 Page 21...
-
Page 22: Wiring Diagrams
S1505B Connection Wiring Diagram THERMOSTAT START STOP RECEPTACLE BUTTON BUTTON BLK -14Ga WHT -14Ga GRN -14Ga POWER MOTOR FUSE BLACK STG 1 STG 2 SWITCH RED GTF -16Ga (HT) RED GTF -16Ga (HT) Page 22 S1505B Manual 974-9308 Rev. 4.32; Aug 29 2014... - Page 23 2nd Stage Valve Thermostat 2nd Stage Contact (NO) 120 VAC Neutral Stop Button Light (Error Light) Alarm Flame Rod Remote Flame Sensor Burner Ground Burner Ground High Voltage Output Spark Plug S1505B Manual 974-9308 Rev. 4.32; Aug 29 2014 Page 23...
-
Page 24: Two Stage Thermostat Wiring Diagram
Thermostat Jumper WHITE BLACK BLUE 1- BLACK 4 - WHITE 120VAC STAGE I I 2 - BLUE 3 - BROWN NEUTRAL STAGE I BROWN FRONT VIEW Thermostat Cable Plug Page 24 S1505B Manual 974-9308 Rev. 4.32; Aug 29 2014... -
Page 25: Lpg - Propane Fuel Vaporization Rate
1 lb./sq. in. (psig) = 27.71" W.C. = 0.0689 bar 1" Mercury = 0.49 psig = 33.86 millibar 1 Std. Cubic Ft./Hr. = 2,500 BTU/Hr. = 0.02832 cu. m/hr. 1 BTU/Hr. = 0.2931 Watts S1505B Manual 974-9308 Rev. 4.32; Aug 29 2014 Page 25... - Page 26 NOTES: Page 26 S1505B Manual 974-9308 Rev. 4.32; Aug 29 2014...
- Page 27 NOTES: S1505B Manual 974-9308 Rev. 4.32; Aug 29 2014 Page 27...
Need help?
Do you have a question about the S1505B and is the answer not in the manual?
Questions and answers