Toro 41568 Operator's Manual page 36

Replacing the Fuses
There are 4 fuses and 4 empty slots in the electrical system.
They are located beneath the driver seat (Fig. 52).
Main electrical system
Speed control
Headlights
Spray system
5
1
Figure 52
1. Spray system
2. Headlights
3. Speed control
Servicing the Battery
Warning
CALIFORNIA
Proposition 65 Warning
Battery posts, terminals, and related accessories
contain lead and lead compounds, chemicals
known to the State of California to cause cancer
and reproductive harm. Wash hands after
handling.
Always keep the battery clean and fully charged. Use a
paper towel to clean the battery and battery box. If the
battery terminals are corroded, clean them with a solution
of four parts water and one part baking soda. Apply a light
coating of grease to the battery terminals to prevent
corrosion.
Voltage: 12 volt with 460 cold cranking Amps @ 0 F
(-18 C)
20 amp
5 amp
10 amp
10 amp
2 3
4
4. Main electrical system
5. 4 open positions
Removing the Battery
1. Position the sprayer on a level surface, set the parking
brake, stop the pump, stop the engine, and remove the
ignition key.
2. Remove the battery retainer and fasteners (Fig. 53).
1
1. Battery
3. Disconnect the negative (black) ground cable from the
battery post.
Warning
Incorrect battery cable routing could damage the
sprayer and cables causing sparks. Sparks can
cause the battery gasses to explode, resulting in
personal injury.
Always disconnect the negative (black) battery
cable before disconnecting the positive (red)
cable.
Always reconnect the positive (red) battery cable
before reconnecting the negative (black) cable.
Warning
Battery terminals or metal tools could short
against metal sprayer components causing sparks.
Sparks can cause the battery gasses to explode,
resulting in personal injury.
When removing or installing the battery, do not
allow the battery terminals to touch any metal
parts of the sprayer.
Do not allow metal tools to short between the
battery terminals and metal parts of the sprayer.
Always keep the battery strap in place to protect
and secure the battery.
36
2
Figure 53
2. Battery retainer