Check Points Of Every 400 Hours; Checking Radiator Hoses And Clamp Bands; Checking Intake Air Line; Replacing Fuel Filter Cartridge (Cartridge Type) - Kubota Z482-E2B Workshop Manual

SM-E2B SERIES, WSM

[8] CHECK POINTS OF EVERY 400 HOURS

Checking Radiator Hoses and Clamp Bands

1. Check to see if the radiator hoses are properly fixed every 200
hours of operation or every six months, whichever comes first.
2. If the clamp is loose, apply oil to the threads and retighten it
securely.
3. The water hose is made of rubber and tens to age. It must be
replaced every two years. Also replace the clamp and tighten it
securely.
(1) Upper Hose

Checking Intake Air Line

1. Check to see if the intake air hose(s) and the breather hose (3)
are properly fixed every 200 hours of operation.
2. If the clamp is loose, apply oil to the threads and retighten it
securely.
3. The intake air hose(s) and the breather hose are made of rubber
and tends to age. It must be changed every two years. Also
change the clamp and tighten it securely.
IMPORTANT
• To prevent serious damage to the engine, keep out any dust
inside the intake air line.
(1) Intake Air Hose
(2) Clamp

Replacing Fuel Filter Cartridge (Cartridge Type)

Water and dust in fuel are collected in the filter cartridge. So,
change the filter cartridge every 400 hours service.
1. Remove the used filter cartridge with filter wrench.
2. Apply a thin film of fuel to the surface of new filter cartridge gasket
before screwing on.
3. Then tighten enough by hand.
4. Loosen the air vent plug to let the air out.
5. Start engine and check for fuel leakage.
(1) Fuel Filter Cartridge
Replacing Fuel Filter Element (Element Type)
1. Close the fuel cock (3).
2. Unscrew the retaining ring (6) and remove the filter cup (5), and
rinse the inside with kerosene.
3. Replace the filter element (4).
4. Reassemble the fuel filter, keeping out dust and dirt.
5. Bleed the fuel system.
(1) Cock Body
(2) Air Vent Plug
(3) Fuel Cock
G-16
G GENERAL
(2) Lower Hose
W1029518
(3) Breather Hose
W1029631
W1050548
(4) Filter Element
(5) Filter Cup
(6) Retaining Ring
W1050583
KiSC issued 06, 2006 A