Advertisement

Kozy-World
OWNER ' S OPERATION AND INSTALLATION MANUAL
GFN4035R
GFN4037R
W A R N I N G :
I m p r o p e r i n s t a l l a t i o n ,
adjustment, alteration, service or maintenance
can cause injury or property damage. Refer to this
manual for correct installation and operational
p ro ced u r es. F o r as si st an ce o r ad d i ti o n al
information, consult a qualified installer, service
agency, or local gas supplier.
WARNING:
This is an unvented gas-fired
fireplace. It uses air (oxygen) f r o m t h e r o o m i n
w h i c h i t i s installed. Provisions for adequate
c o m b u st i o n a n d v en ti l a ti o n ai r mu st b e
p r o v i d ed . Re f e r t o Ai r F o r Combustion and
Ventilation section on page 5 of this manual.
World Marketing of America, Inc.
P. O. Box 192, Rt.. 22 West
Mill Creek, PA 17060
KOZY WORLD PHONE NUMBER :(814)643-1775
http://www.worldmkting.com
R
GFP4036R
GFP4038R
WARNING:
manual is not followed exactly, a f i r e o r
e x p l o s i o n m a y r e s u l t causing property
damage, personal injury, or loss of life.
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
WHAT TO DO IF YOU SMELL GAS
l Do not try to light any appliance.
l Do not touch any electrical switch; do not
use any phone in your building.
l Immediately call your gas supplier from a
neighbor's phone. Follow the gas supplier's
instructions.
l If you cannot reach your gas supplier, call
the fire department. Installation and service
must be performed by a qualified installer,
service agency, or local gas supplier.
This appliance may be installed in an aftermarket*,
permanently located, manufactured (mo b i le)
home, where not prohibited by local codes.
This appliance is only for use with the type of gas
indicated on the rating plate. This appliance is not
convertible for use with other gases.
WATER VAPOR: A BY-PRODUCT OF UNENTED ROOM
HEATERS
Water vapor is a by-product of gas combustion. An unvented
room heater produces approximately one(1) ounce (30ml)
of water for every 1,000 BTU's(.3KW's) of gas input per
hour. Refer to page 4.
*Aftermarket: Completion of sale, not for purpose of resale,
from the manufacturer.
Installer: Please leave these instructions with
the consumer.
Consumer: Please retain these instructions for
future use.
1
FULL SIZE VENT-FREE
FIREPLACE
If the information in this
KW-HL059-03RHW-0505

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the GFN4035R and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Kozy-World GFN4035R

  • Page 1 WHAT TO DO IF YOU SMELL GAS l Do not try to light any appliance. l Do not touch any electrical switch; do not GFN4035R GFP4036R use any phone in your building. l Immediately call your gas supplier from a...
  • Page 2: Table Of Contents

    Table of Contents Safety Information Warnings........3 Product Identification..........4 Air for Combustion and Ventilation......5 Installation..............7 Operating fireplace.............10 Cleaning&Maintenance..........13 Trouble Shooting............15 Specifications.............16 Replacement .............17 Parts List..............18 Installing the Heater............21...
  • Page 3: Safety Information Warnings

    SAFETY INFORMATION WARNINGS 4. This fireplace shall not be installed in a Heater becomes very hot when running IMPORTANT: Read this owner’s manual bedroom or bathroom. fireplace. Keep children and adults away carefully and completely before trying to 5. Do not use this fireplace as a wood-burn- from hot surfaces to avoid burns or cloth- assemble, operate, or service th is ing fireplace.
  • Page 4: Product Identification

    LOCAL CODES SAFETY OVERRIDE CONTROL SYSTEM INFORMATION These fireplaces have two operation lnstall and use fireplace with care. Fol- Continued method: Remote Control and Manual low all local codes. In the absence of C on trol. Th e Remo t e Co nt ro l has a local codes, use the latest edition of The 15.Shut off and unplug fireplace and let transmitter, which requires three AAA bat-...
  • Page 5: Air For Combustion And Ventilation

    AIR FOR COMBUSTION AND VENTILATION Unusually Tight Construction Confined and Unconfined Space WARNING : This fireplace The air that leaks around doors and The National Fuel Gas Code, ANSI shall not be installed in a con- windows may provide enough fresh Z223.1 defines a confined space as fined space or unusually tight air for combustion and ventilation.
  • Page 6 3. Add the Btu/Hr of all fuel burning appliances in the space. Vent-free heater Btu/Hr Example: Gas water heater* Btu/Hr Gas water heater 30,000 Btu/Hr Gas furnace Btu/Hr Vent-free heater 26,000 Btu/Hr Vented gas heater Btu/Hr Total 56,000 Btu/Hr Gas heater logs Btu/Hr Other gas appliances* + Btu/Hr...
  • Page 7: Installation

    INSTALLATION NOTICE : This fireplace is intended for use as supplemental fireplace. Use this fireplace along with your primary heating system. Do not install this fireplace as your primary heat source. If you have a central heating system, you may run the system's circulatin g blower while using the fireplace.
  • Page 8 INSTALLATION Continued CONNECTING TO GAS SUPPLY The installer must supply an external IMPORTANT: Install equipment shutoff regulator. The external regulator will re- valve in an accessible location. The WARNING duce incoming gas pressure. You must : A qualified ser- equipment shutoff valve is for turning on reduce incoming gas pressure to be- vice person must connect fireplace or shutting off the gas to the appliance.
  • Page 9 INSTALLATION Continued CHECKING GAS CONNECTIONS WARNING: Never use an open WARNING: Test all gas piping CAUTION: Make sure external and connections for leaks after install- flame to check for a leak. Apply a mix- regulator has been installed be- ture of liquid soap and water to all ing or servicing.
  • Page 10: Operating Fireplace

    OPERATING FIRE- INSTALLATION Function of Manual ON/OFF Button PLACE Continued and ON/OFF Switch If your remote transmitter is lost or does FOR YOUR SAFETY INSTALLING LOGS n o t f u n c tio n , yo u c an p ress t h e READ BEFORE Manual ON/OFF Button in order to WARNING: Failure to position...
  • Page 11 OPERATING FIRE- b.manual select of main PLACE burner: Press BURNER button, the flame is on Continued “MAN” select. At this selection, the main burner will keep working no matter what the temperature is set at. If there is a need to shut off the main burner, just press the “BURNER”...
  • Page 12 nOPERATIONS OFn Manual Control System nTO TURN OFFn GAS TO APPLIANCE TURN-OFF We provide the manual control system Shutting Off Heater just in case of power shortage. Turn control knob clockwise to the OFF 1. Manual turn-off: when the heater is in Install battery for Manual Ignitor: position.
  • Page 13: Cleaning&Maintenance

    OPERATING FIREPLACE Continued INSPECTING BURNERS BURNER FLAME PATTERN CLEANING AND MAINTENANCE C h e c k p i l o t f l a m e p a t t e r n a n d WARNING: Disconnect power be- burner flame patterns often.
  • Page 14 CLEAN AND MAINTENANCE Continued C l e a n t h e p i l o t a s s e m b l y a l s o . A C A U T IO N : Yo u m u st k ee p CABINET y e l l o w t i p o n t h e p i l o t f l a m e...
  • Page 15: Troubleshooting

    TROUBLESHOOTING NOTE: BEFORE YOU SWITCH TO “ELECTRIC” CONTROL LEVEL FROM MANUAL CONTROL, YOU NEED TO TURN THE KNOB TO “OFF” LEVEL FIRST AND WAIT FOR ONE MINUTE, THEN TURN THE KNOB TO “ELECTRIC”. IN CASE OF “ELECTRONIC” CONTROL LEVEL DOES NOT WORK, PLEASE TURN THE CON- TROL KNOB COUNTERCLOCKWISE TO “OFF”...
  • Page 16: Specifications

    1 . M e t a l e xp an d in g w h i le h e a t in g noise is excessive, contact qualified ser- noise j ust after burner is lit or shut off or contracting while cooling vice person SPECIFICATIONS GFP4036R GFN4035R GFP4038R GFN4037R 40000 40000 Gas Type LP Gas...
  • Page 17: Replacement

    C o n t a c t a u t h o ri zed d ea ler s o f t h is manual. pro duct. If th ey can't supply original replacement part(s) call KOZY-W ORLD’S Technical Service Department at (814)643- 1775 for referral information. When calling KOZY-WORLD or your dealer, have ready Your name Your address Model serial numbers of...
  • Page 18: Parts List

    PARTS LIST GFN4035R GFP4036R This list contains replaceable parts used in your fireplace. W hen ordering parts, follow the instructions listed under Replacement GFN4037R GFP4038R Parts on page 17 of this manual. QT Y KEY NO PART NUM BER DESCRIPT ION...
  • Page 19 PARTS LIST GFN4035R GFP4036R GFN4037R GFP4038R PART KEY NO DESCRIPTION NUMBER GFN4035R GFN4037R GFP4036R GFP4038R HB21-009 Decorating Logs Assembly1 HL001-02 Top Panel HL001-03 Top Panel HL002-02C Upper Panel HL002-03O Upper Panel HL003(4)-03C Side Panel HL003(4)-03O Side Panel HL012-02 Back Panel...
  • Page 20 ILLUSTRATED PARTS BREAKDOWN GFN4035R GFP4036R GFN4037R GFP4038R...
  • Page 21: Installing The Heater

    Installing the Heater 1. Install base and flex tube. l Take out the base from the package l Line the holes on the upper surface of the left and right base with the corresponding holes on the lower surface of the heater, then fasten with self-tapping screws (Figure 1). l Place the mid base between the left and right base on proper position (Figure 2).

This manual is also suitable for:

Gfp4038rGfn4037rGfp4036r

Table of Contents