Winnebago 2010 Navion IQ Operator's Manual
  1. Manuals
  2. Brands
  3. Winnebago Manuals
  4. Motorhomes
  5. 2010 Navion IQ
  6. Operator's manual
Winnebago 2010 Navion IQ Operator's Manual

Winnebago 2010 Navion IQ Operator's Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
About this Manual ............................................................................................................................ 1-1
Safety Messages Used in this Manual .............................................................................................. 1-1
Pre-Delivery Inspection .................................................................................................................... 1-2
Front Axle Tire Alignment ............................................................................................................... 1-2
Service and Assistance ...................................................................................................................... 1-2
Reporting Safety Defects .................................................................................................................. 1-2
Occupant and Cargo Carrying Capacity Label ................................................................................. 1-3
Vehicle Certification Label ............................................................................................................... 1-4
Specifications and Capacitites .......................................................................................................... 1-5
Owner and Vehicle Information ....................................................................................................... 1-6
2010 New Vehicle Limited Warranty ............................................................................................... 1-7
General Warnings ............................................................................................................................. 2-1
Driving Safety ................................................................................................................................... 2-1
Fuel and Propane Gas ....................................................................................................................... 2-1
LP Gas Leaks .................................................................................................................................... 2-2
Propane Gas Leak Detector .............................................................................................................. 2-2
Carbon Monoxide Warning .............................................................................................................. 2-3
Carbon Monoxide Alarm .................................................................................................................. 2-3
Smoke Alarm .................................................................................................................................... 2-4
Fire Extinguisher ............................................................................................................................... 2-5
Electrical ........................................................................................................................................... 2-5
Loading ............................................................................................................................................. 2-5
Maintenance ...................................................................................................................................... 2-5
Emergency Exits ............................................................................................................................... 2-6
Slideout Rooms ................................................................................................................................. 2-6
Formaldehyde Information ............................................................................................................... 2-7
Mold, Moisture, and Your Motor Home ........................................................................................... 2-7
Roadside Emergency ........................................................................................................................ 2-8
Wheel Mounting Nuts (Lug Nuts) .................................................................................................... 2-9
Jump Starting .................................................................................................................................. 2-10
Engine Overheat ............................................................................................................................. 2-10
Seats - Driver/Co-Pilot ..................................................................................................................... 3-1
Seat Belts .......................................................................................................................................... 3-1
Child Restraints ................................................................................................................................. 3-2
Keys .................................................................................................................................................. 3-3
Remote Keyless Entry ...................................................................................................................... 3-3
Rev. 1011110221

TABLE OF CONTENTS

Copyright 2009 Winnebago Industries, Inc. All rights reserved.
Part No. 161500-10-008

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 2010 Navion IQ and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Related Manuals for Winnebago 2010 Navion IQ

Summary of Contents for Winnebago 2010 Navion IQ

  • Page 1: Table Of Contents

    3 – DRIVING YOUR MOTOR HOME Seats – Driver/Co-Pilot ........................3-1 Seat Belts ............................3-1 Child Restraints ..........................3-2 Keys ..............................3-3 Remote Keyless Entry ........................3-3 Rev. 1011110221 Part No. 161500-10-008 Copyright 2009 Winnebago Industries, Inc. All rights reserved.
  • Page 2 Table Of Contents Hazard Warning Flashers ........................3-3 Air Conditioner/Heater – Automotive (Dash) .................. 3-3 Radio In-Dash/Rearview Monitor System ..................3-3 Radio – In-Dash ..........................3-5 Sirius® Plug and Play Satellite Radio ....................3-6 Battery Boost Switch ........................3-7 Engine Cooling System ........................3-7 Lights ..............................
  • Page 3 Table Of Contents House Battery Disconnect Switch ....................6-7 Battery Access ..........................6-7 Battery Care ............................6-8 Circuit Breakers and Fuses – House 12-Volt DC ................6-10 7 – PLUMBING Fresh Water System .......................... 7-1 Water Pump ............................7-2 Cold Water Filter ..........................7-3 Disinfecting Your Fresh Water System ....................
  • Page 4 Table Of Contents Care of Appliques and Decals ......................11-4 Plastic Parts – Cleaning ........................11-4 Exterior Lights ..........................11-5 Interior Soft Goods ......................... 11-5 Ceiling Fabric Care ......................... 11-6 Cabinetry – Cleaning ........................11-7 Tables and Countertops ........................11-8 Galley Sink .............................

  • Page 5: Introduction

    DANGER indicates a hazardous situation are intended as a guide, and in no way which, if not avoided, will result in death or extend the responsibilities of Winnebago serious personal injury. Industries beyond the standard written warranty as presented in this manual.

  • Page 6: Pre-Delivery Inspection

    National Highway Traffic Safety Administration (NHTSA) in addition to notifying Winnebago PRE-DELIVERY INSPECTION Industries, Inc. If NHTSA receives similar complaints, it may...

  • Page 7: Occupant And Cargo Carrying Capacity Label

    SECTION 1 – INTRODUCTION You can also obtain other information about motor vehicle safety from the NHTSA website at http://www.safercar.gov OCCUPANT AND CARGO CARRYING CAPACITY LABEL This label is affixed in the driver’s area next to or near the Vehicle Certification Label. It contains vehicle occupant and cargo carrying capacity along with the number of seat belt positions in the vehicle.

  • Page 8: Vehicle Certification Label

    These pressure levels must be maintained to assure proper handling, safety, 2. Chassis manufacture date. and fuel economy. 3. Month and year of manufacture at Winnebago ® 9. Rear Axle Wheel Configuration: Single or Industries Dual as it relates to the inflation.

  • Page 9: Specifications And Capacitites

    SECTION 1 – INTRODUCTION SPECIFICATIONS AND CAPACITITES 24DL ® Dodge Itasca Navion iQ Sprinter Cab Chassis Feature Number Length 24' 9" 10' 7" Exterior Height Exterior Width 7' 6" Exterior Storage 19.8 cu. ft. Awning Length Interior Height 6' 5" Interior Width 7' 3"...

  • Page 10: Owner And Vehicle Information

    Motor Home Serial Number __________________________________________________________ Chassis Vehicle Identification No. (VIN) ________________________________________________ Vehicle Mileage at Delivery __________________________________________________________ Selling Dealer Name ________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ ® YOUR WINNEBAGO INDUSTRIES DEALER /SERVICE CENTER Name ____________________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ Contact ____________________________________________Phone ________________________ CHASSIS SERVICE CENTER...

  • Page 11: 2010 New Vehicle Limited Warranty

    ITEMS NOT SUBJECT TO WARRANTY COVERAGE Winnebago Industries, Inc. of Forest City, Iowa, warrants each new Chassis, drivetrain and related components* Winnebago and Itasca motor home to the owner for recreational use Wheels* in the U.S.A. and Canada as follows:...
  • Page 12 If you are touring or have moved, contact any unresolved warranty disputes for recreational vehicles. This dispute Winnebago Industries motor home dealer in the United States or resolution program reviews eligible product and service related Canada for warranty service.

  • Page 13: Safety And Precautions

    SECTION 2 – SAFETY AND PRECAUTIONS • Use care when accelerating or decelerating on GENERAL WARNINGS a slippery surface. Abrupt speed changes can cause skidding and loss of control. • Only seats equipped with seat belts are to be occupied while the vehicle is moving. •...

  • Page 14: Lp Gas Leaks

    SECTION 2 – SAFETY AND PRECAUTIONS • All pilot lights must be extinguished and asphyxiation is greater when the appliance is appliances turned off while refilling the fuel used for long periods of time. Failure to comply tank or LP gas tank. could result in death or serious injury.

  • Page 15: Carbon Monoxide Warning

    SECTION 2 – SAFETY AND PRECAUTIONS CARBON MONOXIDE WARNING WARNING EXPLOSION HAZARD: DO NOT use an WARNING open flame to test for gas leaks. When testing for gas line leaks with a soapy water solution, DO NOT use a detergent Avoid inhaling exhaust gases, as they containing ammonia or chlorine.

  • Page 16: Smoke Alarm

    RV application. We recommend obtaining a replacement from your Further Information ® Winnebago Industries dealer. See the manufacturer’s information in your Further Information InfoCase for further instructions.

  • Page 17: Fire Extinguisher

    • Do not remove the radiator cap while engine your coach. We recommend obtaining a and radiator are still hot. Always check replacement only from your Winnebago coolant level visually at the see-through ® Industries dealer or a reliable RV parts supplier.

  • Page 18: Emergency Exits

    SECTION 2 – SAFETY AND PRECAUTIONS • Never get beneath a vehicle that is held up by a jack only. • Do not mix different construction types of tires on the vehicle, such as radial, bias, or belted tires, as vehicle handling may be affected.

  • Page 19: Formaldehyde Information

    SECTION 2 – SAFETY AND PRECAUTIONS MOLD, MOISTURE, AND YOUR MOTOR HOME WARNING What is Mold? Keep all persons clear of the slideout Molds are part of the natural environment. room and moving parts while extending or retracting. Do not occupy the slideout They are as old as the Earth itself and mold room while it is being extended or spores are almost everywhere at some level...

  • Page 20: Roadside Emergency

    • DO NOT jerk your foot off the accelerator. Winnebago Industries ® Just ease back on the accelerator slowly and If Winnebago Industries determines that mold gently to continue momentum. The deflated ® ® is present in the Winnebago /Itasca motor tire will slow the vehicle.

  • Page 21: Wheel Mounting Nuts (Lug Nuts)

    We recommend that you ask for an underlift (wheel lift or frame lift) type towing assembly for safe towing. ® Winnebago Industries does not assume responsibility for damage incurred while towing this vehicle. NOTE: Consult the chassis manual for any...

  • Page 22: Jump Starting

    SECTION 2 – SAFETY AND PRECAUTIONS Spare Tire Mounting Swing-Down Carrier NOTICE -If Equipped Operating a vehicle under a severe overheating condition can result in damage to the vehicle. For information on what to do in case of overheating, consult your chassis manual. JUMP STARTING If your coach will not start from the chassis battery, try using the battery boost switch to...

  • Page 23: Driving Your Motor Home

    The information in this section refers only to 1- Insert tab into buckle features installed or adapted to the dash and slot until it “clicks” and is driver compartment area by Winnebago locked ® Industries . It also includes passenger seating in the living area of the coach.

  • Page 24: Child Restraints

    SECTION 3 – DRIVING YOUR MOTOR HOME Seat Belt Care and Cleaning 4. Review the instructions for installation and use of the restraint. Be sure that you • Be careful not to damage the belt webbing and understand them fully and can install the hardware.

  • Page 25: Keys

    SECTION 3 – DRIVING YOUR MOTOR HOME KEYS AIR CONDITIONER/HEATER – AUTOMOTIVE (DASH) Your motor home is supplied with several keys. In addition to the chassis manufacturer’s See your chassis manual for operating ignition key, you receive keys for the entrance information on driver and passenger comfort door and exterior compartment doors.

  • Page 26: Radio Remote Controls

    SECTION 3 – DRIVING YOUR MOTOR HOME iPod Cable • AUDIO - Press and hold access AUDIO MENU. Press to return to current playback -If Equipped mode. Your coach is equipped with a cable to • CAM - Press to access CAMERA mode. connect your iPod to play through your radio.

  • Page 27: Radio - In-Dash

    SECTION 3 – DRIVING YOUR MOTOR HOME Radio Power Switch (Located in dash area) -Typical View Please refer to the manufacturer’s operating guide in your InfoCase for detailed instructions Radio Sound through Deluxe on programming preset station buttons and using Sound Speakers this full-featured radio/audio system.

  • Page 28: Sirius Plug And Play Satellite Radio

    SECTION 3 – DRIVING YOUR MOTOR HOME NOTE:The Coach/House Battery Disconnect Switch must be on while listening to the dash radio because the audio relay is powered by house batteries. If the Coach/ House Battery Disconnect Switch is off, the speakers will not emit sound. -Typical View See the manufacturer’s information in your InfoCase for operating instructions.

  • Page 29: Battery Boost Switch

    SECTION 3 – DRIVING YOUR MOTOR HOME Further Information to different locations and enjoy your favorite programming (separate docking station See the Sirius user guide provided in your included). InfoCase for complete operating and installation instructions. BATTERY BOOST SWITCH This switch can be used to draw emergency starting power from the house batteries to start the engine if the chassis battery is discharged.

  • Page 30: Lights

    SECTION 3 – DRIVING YOUR MOTOR HOME SUSPENSION ALIGNMENT NOTICE AND TIRE BALANCE When refilling the coolant system of a The front suspension and steering system of vehicle equipped with a rear auxiliary this vehicle was factory aligned using highly automotive heater and motoraid water accurate equipment prior to delivery to the heater, be sure to allow for additional...
  • Page 31 SECTION 3 – DRIVING YOUR MOTOR HOME downshifting. Select the lowest adequate gear range for the duration of the incline. See your chassis manual for specific information. Descending A Hill When going down a long grade, you may need to manually shift to a lower gear rather than keeping your foot on the brake pedal.

  • Page 33: Appliances And Systems

    SECTION 4 – APPLIANCES AND SYSTEMS The appliances installed in your motor home are manufactured by reputable RV appliance makers and have been tested by independent laboratories to meet all applicable standards and codes set for RV appliances. See Section 2 of this manual for any safety and precautions you need to take regarding the operation of your appliances.

  • Page 34: Refrigerator Service Access Compartment

    SECTION 4 – APPLIANCES AND SYSTEMS To Open: 1. Use a screwdriver or coin to turn the latch knobs to the vertical position as shown. Refrigerator Access Door Latches • Gas- Refrigerator will operate on gas from the propane tank if the main valve is open and the 2.

  • Page 35: Microwave Oven

    SECTION 4 – APPLIANCES AND SYSTEMS WARNING Portable fuel-burning equipment including wood and charcoal grills and stoves, shall not be used inside the recreational vehicle. The use of this equipment inside the recreational vehicle can cause fires or asphyxiation. Failure to comply could result in death or serious injury.

  • Page 36: Systems Monitor Panel

    SECTION 4 – APPLIANCES AND SYSTEMS Further Information See the appliance manufacturer’s information provided in your InfoCase for instructions on replacement of light bulbs and replacement or cleaning of grease filter elements. The approximate fluid levels are measured by electronic sensors on the sides of the tanks. There is generally more fluid in a tank than indicated on the monitor panel.

  • Page 37: Water Heater - Gas

    SECTION 4 – APPLIANCES AND SYSTEMS The propane level is registered by a sending WATER HEATER – GAS unit on the tank. The gauge mounted on the side of the tank will give a more accurate indication of NOTE: Read the Water Heater Operating Guide actual tank level if needed.

  • Page 38: Water Heater - Gas/ Electric

    SECTION 4 – APPLIANCES AND SYSTEMS WATER HEATER - GAS/ ELECTRIC –If Equipped (with Motoraid water heating system) The gas/electric water heater has a dual power feature. It can operate from propane gas or 120- volt house current; or it can use both at the same time for quicker recovery at times when you are using a lot of hot water.

  • Page 39: Motoraid Water Heater

    SECTION 4 – APPLIANCES AND SYSTEMS Further Information Read the operating and safety information provided in the Water Heater Operation Manual in your InfoCase. MOTORAID WATER HEATER –If Equipped The motoraid uses heat from the chassis engine cooling system to heat water in the water heater while driving.

  • Page 40: Propane Gas Furnace

    SECTION 4 – APPLIANCES AND SYSTEMS Lift handle straight out to open P-T valve Thermostat Switch Temp Selector when water heater is cold* • Move to Heat or • Press up or Gas position for down to select 4. Let the handle of the P-T valve snap shut. furnace operation temperature 5.

  • Page 41: Heat Pump

    SECTION 4 – APPLIANCES AND SYSTEMS Further Information temperatures begin to reduce the efficiency of the heat pump. The heat pump will not operate when Please see the furnace operating instructions the outside temperature falls below 36 degrees F. provided in your InfoCase for further information, including operating precautions, To operate the heat pump: and periodic maintenance.

  • Page 42: Air Conditioner Filter

    SECTION 4 – APPLIANCES AND SYSTEMS Further Information NOTE: The ducted roof air conditioning system has ceiling registers that can be closed if Refer to the air conditioner manufacturer’s necessary to force more cool air toward information in your InfoCase for complete a specific area of the coach or to route operating instructions.

  • Page 43: Propane Gas

    SECTION 5 – PROPANE GAS PROPANE GAS SUPPLY The propane gas system supplies fuel for the gas range/oven, water heater, furnace, and refrigerator (while in gas mode). When used and handled properly, this system is safe and economical and provides modern living conveniences wherever you travel.

  • Page 44: Safe Use Of The Propane Gas System

    SECTION 5 – PROPANE GAS phone directory yellow pages for locations of local propane gas refilling stations or bulk dealerships. DAN G E R NOTE: If you travel outside the U.S. with your motor home, you may find butane or DO NOT FILL CONTAINER TO MORE propane/butane mixtures available in THAN 80 PERCENT OF CAPACITY.

  • Page 45: Propane Gas Warnings And Precautions

    SECTION 5 – PROPANE GAS • Exercise caution at all times. Be familiar with PROPANE GAS WARNINGS the distinctive odor of propane gas. If a leak is AND PRECAUTIONS suspected, turn off the supply valve immediately. Have the propane gas system It is illegal for vehicles equipped with propane checked by your dealer or other qualified tanks to travel on certain roadways or through...

  • Page 46: Propane Gas Pressure Regulator

    SECTION 5 – PROPANE GAS WARNING WARNING Propane cylinders shall not be placed or Visually inspect the pressure regulator stored inside the vehicle. Propane vent periodically for blockage by cylinders are equipped with safety accumulated debris or insect nests, etc. devices that relieve pressure by Vent obstruction could result in excessive discharging propane to the atmosphere.

  • Page 47: Propane Vaporization In Cold Weather

    SECTION 5 – PROPANE GAS This means that in extremely cold weather when a large volume of gas is being used by the furnace for heating, it is possible to experience a loss of gas pressure. At first, this problem may appear to be caused by an empty tank or a regulator freeze-up, but is actually caused by failure of the liquid gas to vaporize as fast as it is needed by the furnace.

  • Page 49: Electrical

    SECTION 6 – ELECTRICAL Your coach is equipped with an electrical the power converter automatically changes a system consisting of two separate voltages: portion of the 120-volt current to 12-volt DC current. All equipment in the motor home that is •...
  • Page 50 SECTION 6 – ELECTRICAL The three-prong power cord is designed to ground the electrical system through the receptacle. It is also designed to carry the amperage output of most campground outlets. 30 Amp Receptacle • Route power cord through notch and close door while shoreline is connected to outlet If the electrical receptacle to be used is designed to mate with the three prongs on the...

  • Page 51: Power Center

    SECTION 6 – ELECTRICAL The converter power panel contains the house electrical system 120-volt circuit breakers and 12-volt fuses. The power converter changes 120-volt AC current from the auxiliary generator or the shoreline into 12-volt DC current for use by 12- volt equipment in the motor home.

  • Page 52: Circuit Breakers - House 120-Volt Ac

    SECTION 6 – ELECTRICAL Further Information CIRCUIT BREAKERS – HOUSE See the manufacturer’s operation, care, and 120-VOLT AC maintenance information in your InfoCase. The breaker panel protects all 120-volt Charging Section components in the motor home from either an overload on the circuit or a short in the wiring or The converter charges house batteries while component itself.

  • Page 53: Ground Fault Circuit Interrupter

    SECTION 6 – ELECTRICAL GROUND FAULT CIRCUIT ELECTRICAL GENERATOR – INTERRUPTER 120-VOLT –If Equipped Bath, galley, and exterior outlets are connected to a GFCI (Ground Fault Circuit Interrupter), which is an extremely sensitive WARNING circuit breaker that will help to protect against severe electrical shock if a ground fault develops.

  • Page 54: Electrical System - House 12-Volt Dc

    SECTION 6 – ELECTRICAL Generator Hourmeter Operation Warnings and Cautions The generator hourmeter registers the total number of hours that the generator has been WARNING operated. The following hourmeters are located on or next to the monitor panel in your coach. The exhaust of all internal combustion engines contains carbon monoxide (CO).

  • Page 55: House Battery Disconnect Switch

    SECTION 6 – ELECTRICAL Chassis Battery Always leave this switch ON while using the coach. The chassis battery is used to operate the engine starter and automotive accessories and NOTE: Some electronic displays and memory controls found on the instrument panel. The functions may need to be reset after slideout room systems and the electric step are power has been reconnected.

  • Page 56: Battery Care

    SECTION 6 – ELECTRICAL House Batteries Chassis Battery Connector NOTE: Some models may be equipped with only (Located to the right of the one house battery. accelerator pedal) Chassis Battery Further Information The chassis (starting) battery is located in a See the chassis manual provided in your compartment “well”...
  • Page 57 SECTION 6 – ELECTRICAL The two best defenses against sulfating • Neutralize corrosion buildup or acid film on and insufficient charge are to: top of battery by washing with a baking soda/ water solution. Rinse with clear water. 1. Turn off the House/Coach Battery Disconnect (House/Coach Batt) switch to avoid parasitic NOTE: Make sure vent caps are on securely to discharge (the trickle discharge caused by...

  • Page 58: Circuit Breakers And Fuses - House 12-Volt Dc

    SECTION 6 – ELECTRICAL 12-Volt Fuse Panel The fuse panel is on the right-hand side of the WARNING power converter. 12-Volt House Fuses To prevent wiring damage, it is essential when replacing the cables on the battery, or when using a “booster” battery, that the positive post and the positive cable be attached and the negative post and negative cable be attached.

  • Page 59: Plumbing

    SECTION 7 – PLUMBING FRESH WATER SYSTEM The fresh water system provides water to the galley sink, shower, bathroom lavatory, toilet and water heater. Water may be supplied by either of two sources: • a fresh water tank and water pump located within the motor home, or •...

  • Page 60: Water Pump

    SECTION 7 – PLUMBING 2. Turn Fresh Water Valve to Normal position Water pressure regulators are commonly and turn the water pump switches OFF. available at most RV dealerships and many large retail discount or home supply centers. WATER PUMP When your coach is not connected to a city water supply, water is supplied from the fresh water tank by a water system demand pump.

  • Page 61: Cold Water Filter

    SECTION 7 – PLUMBING Initial Waterline Priming 1. Make sure that all water drain valves are closed, including water heater valve. 2. Turn water pump switch to “OFF” position. 3. Fill water tank. 4. Open all faucets, hot and cold. 5.

  • Page 62: Disinfecting Your Fresh Water System

    SECTION 7 – PLUMBING • Purge a new filter cartridge before using for drinking. Run a few gallons of water through the filter and discard the water (or use for watering plants) to avoid ingesting carbon dust or particles that may have been present in the new filter cartridge.
  • Page 63 SECTION 7 – PLUMBING This procedure is also recommended before water system. (If a 100 ppm concentration is long periods of storage, such as over winter. desired as discussed in step 3, use 1 cup of household bleach for each 30 gallons of tank Models with City Water Tank Fill capacity.) The bleach will be drawn into the tank when...

  • Page 64: Shower Hose Vacuum Breaker

    SECTION 7 – PLUMBING upright to avoid draining the bleach. EXTERIOR SHOWER/WASH Connect the hose to a city water hydrant to force STATION the bleach into the tank and fill the tank with water. –If Equipped This method has the additional benefit of disin- The exterior wash station feature allows you fecting the city water hose at the same time.

  • Page 65: Waste Water System

    SECTION 7 – PLUMBING the holding tank. Toilet tissue made specifically for use in RV toilets and holding tanks is available at most RV supply centers. • Don’t dispose of sanitary napkins or other non-dissolving items in the toilet. • Don’t put automotive antifreeze or caustic chemicals, such as laundry bleach or heavy detergents into the toilet or holding tank.

  • Page 66: Dumping Holding Tanks

    SECTION 7 – PLUMBING Dust Cap Sewage Drain Outlet Sewage Drain Outlet (Located ahead of rear driver side wheel) -Typical View Waste Pump (Shown with panel removed) 3. Place the outlet end of sewer hose into -Remove cap and manually turn disposal opening.

  • Page 67: Holding Tank Heater

    SECTION 7 – PLUMBING 5. Open the gray water drain valve and hold the NOTE: We recommend that you dump all waste pump switch (located in the water holding tanks before traveling to avoid service center). Release the waste pump carrying unnecessary weight.

  • Page 68: Waterline & Tank Drain Valves

    SECTION 7 – PLUMBING D R A I N D R A I N C L O S E C L O S E L I N E - E N D V A L V E I N - L I N E V A L V E Waterline Drain Valves (Typical)

  • Page 69: Water Heater Bypass Valve

    SECTION 7 – PLUMBING Waterline Drain Valves WATER HEATER BYPASS VALVE NOTE: This waterline drain valve is NOT used with the exterior shower Your coach may be equipped with a water option. With the exterior shower heater bypass valve for easier winterization of option, waterlines run through the waterlines using RV antifreeze.
  • Page 70 SECTION 7 – PLUMBING Method 1 – Blow Out Procedure • Twist the filter cartridge counter-clockwise (to the left) about one-quarter turn, then pull (Drain and purge waterlines using it down and out of the filter socket. Discard compressed air) used filter.
  • Page 71 A “blow-out” plug can be closed. ® ® purchased at any Winnebago or Itasca Do not add automotive antifreeze or dealer. caustic chemicals such as bleach or laundry detergents into the toilet bowl or holding tanks.
  • Page 72 SECTION 7 – PLUMBING Dump and Clean Holding Tanks 16. Completely drain the sewage and waste water WARNING holding tanks at an approved waste disposal site. Drain the sewage tank first so the following waste water can rinse any waste NEVER use automotive antifreeze/ solids from the dump outlet and sewer hose.
  • Page 73 SECTION 7 – PLUMBING 4. Remove and save the protective cap from the end of the antifreeze siphon tube (which connects to Winterization Valve 2). Insert the end of the siphon tube into a pail or other container with 2 to 3 gallons of non-toxic RV antifreeze solution.
  • Page 74 SECTION 7 – PLUMBING Drain Water Heater 13. Pour about one cup of RV antifreeze down each drain for the galley sink, lavatory sink, 11. Turn off the Water Heater power switch and shower/tub. This fills the drain trap pipes before draining the water heater tank to avoid to prevent holding tank odors from entering damage to the heating element.

  • Page 75: Water System Drain Valve Locations

    SECTION 7 – PLUMBING WATER SYSTEM DRAIN VALVE LOCATIONS Model System Drain Valve Locations 24DL Waterlines Beneath removable access panel in floor of lavatory cabinet and left rear area accessed from backwall compartment door. Water Tank Large yellow-handled valve in left rear of coach accessed through backwall compartment door.

  • Page 77: Entertainment

    SECTION 8 – ENTERTAINMENT TV – 12-VOLT LCD AUDIO-VIDEO SYSTEM BASIC OPERATION –If Equipped The liquid crystal display flat panel TV is NOTE: For your convenience, we have also powered by 12-volt DC current. included a handy, tear-out version of this The TV 12V Master Power Switch must be “A/V System Basic Operation”...

  • Page 78: Exterior Speakers

    SECTION 8 – ENTERTAINMENT Provide 12V Power • When the main menu screen appears, press The TV and DVD player the ENTER button on operate on 12-volt DC the remote or “Play/ current. Pause” button on DVD • Turn on the 12-Volt player to begin playing Master Power (TV) the main feature.

  • Page 79: Tv Antenna

    SECTION 8 – ENTERTAINMENT See the antenna manufacturer’s operation, care and maintenance information in your InfoCase. WARNING Never allow the antenna to touch electrical power lines or any other electrical wires. Exterior Speaker (Located below patio awning) Raising Antenna to Operating Position -Typical View Turn elevating crank clockwise in “UP”...

  • Page 80: Tv Signal Amplifier

    SECTION 8 – ENTERTAINMENT Turn elevating crank (counter-clockwise) in An indicator light will glow when the switch “DOWN” direction until resistance is noted is on and the signal amplifier is active. (about 13 turns). Antenna is now locked in travel position.
  • Page 81 SECTION 8 – ENTERTAINMENT ® See your authorized Winnebago Industries dealer for proper installation and sealing of roof mounted components. Interior Connection for Satellite Dishes (Located in cabinet near TV)

  • Page 83: Furniture And Softgoods

    SECTION 9 – FURNITURE AND SOFTGOODS SLEEPING FACILITIES WARNING Sleeping facilities are not intended for use while vehicle is in motion. For safety, passengers must use safety belted seating positions while vehicle is in motion. DINETTE/BED CONVERSION –If Equipped (Typical view – your coach may differ) Dinette to Bed 1.
  • Page 84 SECTION 9 – FURNITURE AND SOFTGOODS Reverse Steps 1-5 to convert back into dinette seating. Dinette Table Extension 1. Lift up on dinette table floor mechanism underneath the table to release from floor support. 4. Remove bed legs from beneath dinette seat and set on floor.

  • Page 85: Day/Night Pleated Blinds

    SECTION 9 – FURNITURE AND SOFTGOODS out harsh direct sunlight to help keep the inside of the coach cool in summer or to disperse light for houseplants. Room Darkening/Privacy Shade The upper section is an opaque, darkening shade for nighttime privacy and daytime room darkening purposes.

  • Page 86: Wood Furniture And Cabinetry

    With the blind fully lowered, dampen the No matter which species you choose for your entire area of the pleats with a good quality new Winnebago Industries motorhome laundry spray starch. cabinetry, please keep in mind that no two pieces of wood are exactly the same.

  • Page 87: Slideout Rooms

    SECTION 10 – SLIDEOUT ROOMS To Secure Lock Rod SLIDEOUT ROOM TRAVEL • Place the flat plate end of the lock rod against LOCK the outer wall of the coach about 6” down –If Equipped from the top edge of the forward end of the retracted slideout room (behind the driver seat Some models are equipped with an in most cases).

  • Page 88: Slideout Room Operation - Electric

    SECTION 10 – SLIDEOUT ROOMS To Extend Slideout Room SLIDEOUT ROOM OPERATION – ELECTRIC Before Extending! • Level the coach and set the Parking Brake. Slideout rooms provide a spacious living area • Release the travel lock or latch (if equipped) at the push of a button.

  • Page 89: Slideout Room - Extreme Weather Precaution

    SECTION 10 – SLIDEOUT ROOMS To Retract Slideout Room • After the room is retracted, deactivate the slideout switch with the Safety Lock key, then Before Retracting! refasten the travel lock or latch inside the coach (if equipped). • Be sure the coach is level and the Parking Brake is set.

  • Page 90: General Slideout Care

    SECTION 10 – SLIDEOUT ROOMS Crank-In Procedure Further Information See the slideout manufacturer’s user guide 1. Disengage the motor brake, which appears as provided in your InfoCase for further instructions a flat “square” protrusion on the protective and troubleshooting information. boot at the end of the motor.

  • Page 91: Maintenance And Storage

    • Have the sealant replaced if you notice any of attention. Delaying these repairs may allow water the above. Your local Winnebago Industries leakage and result in damage to interior ceiling dealer has the correct and necessary parts and and body panels, upholstery, etc., which is not experience to help you maintain your sealants.

  • Page 92: Exterior Automotive Paint Finish

    SECTION 11 – MAINTENANCE AND STORAGE weight to the vehicle. This, in effect, reduces the initial 60-day cure stage, a coat of wax or amount of cargo you can carry and remain within polish can help protect the surface from these GVWR and GAWR limits.
  • Page 93 SECTION 11 – MAINTENANCE AND STORAGE Bug Removal to clean heavy road films on semi trailers and are often dirty. They are not • Rinse the loose debris off with water and designed for custom painted RV’s and allow the remaining residues to soak and they will scratch the clearcoat finish.

  • Page 94: Care Of Appliques And Decals

    SECTION 11 – MAINTENANCE AND STORAGE is subjected to various twisting and flexing forces • Fuel or antifreeze spilled on appliques or caused by routine cornering and turning, and by decals should be rinsed off immediately with uneven road surfaces, such as bumps, potholes, water.

  • Page 95: Exterior Lights

    • Butyl alcohol home is parked for an extended period of time. EXTERIOR LIGHTS ® Most Winnebago Industries vehicles have WARNING polycarbonate lenses on exterior lamps, which are very sensitive to a variety of chemical solvents and cleaners. When cleaning upholstery and fabric, do...

  • Page 96: Ceiling Fabric Care

    SECTION 11 – MAINTENANCE AND STORAGE Care Instructions These materials are made from polypropylene or polyester synthetic fibers, so they clean very • Spot clean with mild soap and water. well with virtually no damage to the color or • Air dry or, if desired, dry quickly using a hair fabric itself.

  • Page 97: Cabinetry - Cleaning

    SECTION 11 – MAINTENANCE AND STORAGE The following cleaning chart is provided as a guideline for care and cleaning of ceiling fabrics used in your coach. CEILING FABRIC STAIN REMOVAL Type of Stain Cleaning Agent How to Remove Mustard Dry-Clean Solvent Scrub-Soak-Blot Dry Ketchup* High Strength Detergent...

  • Page 98: Tables And Countertops

    SECTION 11 – MAINTENANCE AND STORAGE Vinyl simulated wood panels may be cleaned • A high iron content in the water (hard water) with a mild, water-based cleaner and a soft cloth. may result in a brown or rust-colored stained Do not use solvents on vinyl wood panels.

  • Page 99: Doors And Windows

    SECTION 11 – MAINTENANCE AND STORAGE Lavatory Sink batteries, turn the Aux/Coach Battery Switch off to avoid electrical arcing when attaching The lavatory sink is made of the same material and detaching charge clamps. as the galley sink. See Galley Sink - Care and Cleaning Instructions.

  • Page 100: Vehicle Storage - Removal

    SECTION 11 – MAINTENANCE AND STORAGE 17. After washing accumulated winter grime VEHICLE STORAGE – from the vehicle, it is important to carefully REMOVAL inspect the seams and sealants for separation or cracks that may have appeared around the 1. Completely air out the motor home. window frames, vents, and any other joints.

  • Page 101: Coach Maintenance Chart

    SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Propane Gas System Have propane gas system checked for leaks Pressure Regulator - inspect and adjust if needed Check propane tank condition, mounting, and fittings...
  • Page 102 SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Safety Equipment Check operation of the following items: Headlights, Taillights, and Marker Lights Turn Signals...
  • Page 103 SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Sealants Inspect (see “Sealants”...

  • Page 105: Miscellaneous

    SECTION 12 – MISCELLANEOUS NOTE: We recommend that you dump all LOADING THE VEHICLE holding tanks before traveling to avoid carrying unnecessary weight. NOTE: Your motor home’s load capacity is designated by weight, not by volume, so you cannot necessarily use all available space when loading your motor home.
  • Page 106 SECTION 12 – MISCELLANEOUS Corner Weighing (Side-to-Side) You will first drive only your front wheels onto the scale pad, then drive ahead so that the The most accurate method of weighing a whole vehicle is on the scale, then finally pull off motor home is to weigh each “corner”...

  • Page 107: Car Or Trailer Towing

    SECTION 12 – MISCELLANEOUS axle is 12,000 lbs., then the load on each rear dual listed Gross Weight Ratings. See “Vehicle set (left rear duals or right rear duals) should not Certification Label” in the Introduction section exceed 6,000 lbs. for information on gross weight ratings.

  • Page 108: Trailer Wiring Connector

    SECTION 12 – MISCELLANEOUS Before descending a steep or long grade when TRAILER WIRING towing a trailer, reduce speed and shift into a CONNECTOR lower gear to control vehicle speed. Avoid prolonged or frequent application of brakes Your coach is pre-wired for trailer or car which could cause overheating and brake failure.

  • Page 109: Entry Step - Electric

    350 vehicle drive train: engine and cooling systems, lbs. All Winnebago Industries models transmission, drive line, drive axle, and others. equipped with a Class IV hitch have a...

  • Page 110: Windows

    SECTION 12 – MISCELLANEOUS Stationary Extended Mode - Step Switch OFF (Step Remains Extended) With the Step power switch in the OFF position, the step will extend when the screen door is opened and will stay extended whether the door is opened or closed. This position is normally used to keep the step extended when parked at a campsite or whenever people will be going in and out the vehicle...

  • Page 111: Power Roof Ventilator

    SECTION 12 – MISCELLANEOUS Vertical Slider Windows • Pull out the lever on the crank-out handle and begin cranking out the window counter- Vertical windows have spring-loaded catches clockwise to the position desired. on both sides of the window that pop out to hold the window in its fully raised position.

  • Page 112: Storage Compartment Doors

    SECTION 12 – MISCELLANEOUS To Operate Ceiling Ventilator STORAGE COMPARTMENT 1. Turn the Dome Crank Knob to raise the dome DOORS about 3" or more to allow the turbine fan to operate. (A built-in safety switch will not let the fan motor run unless the dome is partially open).

  • Page 113: Power Awning

    SECTION 12 – MISCELLANEOUS POWER AWNING –If Equipped The awning control switch is located near the entrance door. Press to Retract Press to Extend To Close Exterior Compartment Door 1. Turn handle back to horizontal position to Awning Control Switch latch door.
  • Page 114 SECTION 12 – MISCELLANEOUS moisture can cause water stains or mildew, which can damage interior items such as upholstery and cabinets. When you recognize the signs of excessive moisture and condensation in your coach, you should take immediate action to minimize their effects.
  • Page 115 INDEX 2010 New Vehicle Limited Warranty ..1-7 Engine Overheat ........2-10 About this Manual ........1-1 Entry Step – Electric ........12-5 Air Conditioner Filter ........ 4-10 Exterior Automotive Paint Finish ....11-2 Air Conditioner/Heater – Exterior Lights ........... 11-5 Automotive (Dash) ........
  • Page 116 Index Power Roof Ventilator ....... 12-7 Tables and Countertops ......11-8 Pre-Delivery Inspection ....... 1-2 Tires ............. 3-8 Pressure-Temperature Relief Valve ..... 4-7 Toilet ............7-6 Propane Gas Furnace ........4-8 Towing Guidelines ........12-4 Propane Gas Leak Detector ......2-2 Trailer Wiring Connector ......

Table of Contents