Daily Inspection - TOHATSU M 2.5A2 Owner's Manual

1. Daily inspection

Perform the following checks before
and after use.
Item
• Check the amount of fuel in the tank.
Fuel System
• Check for debris or water in the fuel filters.
• Check that the stop sw tch functions normally and make
Electrical
Equipment • Check cords for loose connections and damage.
• Check the spark plugs for dirt, wear and carbon build-up.
• Check the rope for wear and chafing.
Recoil Starter
• Check the ratchet engagement.
• Visually Check propeller for bent or damaged blades.
Clutch and
• Check the propeller nut is tightened and the spl t pin is
Propeller System
• Check all the bolts attaching the motor to the boat.
Installation of
• Check the thrust rod installation.
Motor
• Check that cooling water is discharged from the cooling
Cooling Water
• Check that there are tools and spare parts for replacing
Tools and Spares
• Check that you have the spare rope.
• Check if the anode is securely installed.
Anode
• Check the anode for corrosion and deformation.
Points to Check
sure the lock plate is there.
present.
water check port after the engine has started.
spark plugs, the propeller, etc.
INSPECTION AND MAINTENANCE
�������
!
Do not use outboard motor if any
abnormality is found during pre-
operation check or it could result in
severe damage to the motor or severe
personal injury.
35
Action
Replenish
Clean or replace
Remedy or replace
Correct or replace
Clean or replace
Replace
Correct or replace
Replace
Tighten
Adjust
Repair
Repair or Replace
9