Rear Axle; Checking The Lubricant Level; Air Cleaner Inspection And Replacement; Cleaning The Air Filter Element - Cushman refresher fs4 Owner's Manual

MAINTENANCE
Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.

REAR AXLE

The rear axle is provided with a lubricant level check plug located on the driver side at the rear of the housing. Unless
leakage of rear axle lubricant is evident, an annual lubricant check is sufficient.

Checking the Lubricant Level

Tool List
Socket, 13 mm ............................................................ 1
Ratchet ........................................................................ 1
Drain Plug

AIR CLEANER INSPECTION AND REPLACEMENT

The air cleaner unit on the vehicle is a dry unit. Do not use oil on the filter element or any part of the unit. To aide instal-
lation and sealing, petroleum jelly may be applied to back side of cover tabs and each side of filter seal.

Cleaning the Air Filter Element

Do not use compressed air to clean the air filter. Compressed air will damage the filter which may result in
52
Qty. Required Tool List
Funnel ......................................................................... 1
Clean area around the check and fill plugs. Remove check
Fill / Check Plug
plug. The correct lubricant level is just below bottom of
threaded hole. If lubricant is to be added, remove the fill plug
and add lubricant using a funnel. Add lubricant slowly until
lubricant starts to seep from the check plug hole. Install check
plug and fill plug. In the event that lubricant is to be replaced, a
drain plug is provided at the bottom of the differential housing.
damage to the engine.
Owner's Guide
Qty. Required