Troubleshooting; Blown Fuse Or Circuit Breaker; Gate Does Not Open. Agitator Does Not Turn; Gate Does Not Open Or Is Sluggish. Agitator Turns - Cornelius enduro 200 Operator's Manual

IMPORTANT: Only qualified personnel should service internal components or electrical wiring.
WARNING: If repairs are to be made to a product system, remove quick disconnects from
the applicable product tank, then relieve the system pressure before proceeding. If repairs
are to be made to the CO
system pressure before proceeding. If repairs are to be made to the refrigeration system, make sure
electrical power is disconnected from the unit.
Should your unit fail to operate properly, check that there is power to the unit and that the hopper con-
tains ice. If the unit does not dispense, check the following chart under the appropriate symptoms to aid
in locating the defect.

BLOWN FUSE OR CIRCUIT BREAKER.

GATE DOES NOT OPEN. AGITATOR DOES NOT
TURN.
GATE DOES NOT OPEN OR IS SLUGGISH.
AGITATOR TURNS.

ICE DISPENSES CONTINUOUSLY.

SLUSHY ICE. WATER IN HOPPER.

BEVERAGES DO NOT DISPENSE.

BEVERAGES TOO SWEET.

92108OPR

TROUBLESHOOTING

system, stop dispensing, shut off the CO
2
Trouble Probable Cause
A. Short circuit in wiring.
B. Defective gate solenoid.
C. Defective agitator motor.
A. No power.
B. Bent depressor plate (does not actuate switch).
C. Defective dispensing switch.
A. Defective gate solenoid.
B. Excessive pressure against gate slide.
C. Defective Rectifier.
A. Stuck or bent depressor plate (does not
release switch).
B. Defective dispensing switch.
C. Improper switch installation.
A. Blocked drain.
B. Unit not level.
C. Poor ice quality due to water quality or
icemaker problems.
D. Improper use of flaked ice.
A. No 24 volt power to faucets.
B. No CO pressure.
2
A. Carbonator not working.
B. No CO pressure in carbonator.
2
C. Faucet brix requires adjusting.
6
supply, then relieve the
2