Detergent And Rinse Aid Dispenser; Drying Assist Fan - GE Monogram ZBD6400 Series Technical Service Manual

6000 & 7000 Series DISHWASHERS

5.2.39 Detergent and Rinse Aid Dispenser

CAUTION. Switch off electrical power supply.
5.2.39.1. Remove the dishwasher outer Door Panel.
5.2.39.2. Remove the six retaining screws which fix the
Detergent and Rinse Aid Dispenser to the stainless steel
door liner through upper and lower fixing brackets. The
Thermistor Retaining Clip is attached to the right hand corner
of the upper fixing bracket.
5.2.39.3. Remove the Detergent and Rinse Aid Dispenser
from the stainless steel door liner.
5.2.39.4. Upon reinstallation of a Detergent and Rinse Aid
Dispenser to the stainless steel door liner ensure the sealing
face area is clean and free from damage. To ensure an
effective seal between the Dispenser seal and the stainless
steel door liner face, alternatively tension the two centre
screws through the upper and lower brackets and then the
upper and lower corner screws.
NOTE: The right hand upper corner screw also clamps the
thermistor retaining clip to the bracket face. Slide the
thermistor retaining clip over to the body of the dispenser by
means of the slotted mounting hole. Tighten the mounting
screw which will cause the thermistor retaining clip to bend
and pretension the end of the clip to retain the thermistor. The
end of the thermistor protrudes through the mounting clip by
1/4" to 3/8"
5.2.39.5. Reassemble the dishwasher in reverse order.
5.2.39.6. Operate and test dishwasher before leaving.
Dispenser Thermistor
1/4" to
3/8"

5.2.40 Drying Assist Fan

CAUTION. Switch off electrical power supply.
5.2.40.1 The drying assist fan is located in the top left hand
corner of the stainless steel door liner. To access the fan
remove the outer door panel and the control panel.
5.2.40.2 To remove the fan from the inner door, release the
fan grill by using pointed nose pliers (refer to below) to turn
it 1/8 of a turn in a counter clockwise direction as shown be-
low.
5.2.40.3 Remove the 1/4" terminals then lift the condensate
duct and the drying assist fan clear.
Condensate Duct 1/4" Terminals
Stainless Steel Door Liner
5.2.40.4 Operate and test dishwasher before leaving.
Pliers
Fan Grill
Door Liner
Drying Assist Fan
PAGE 58