Table Of Contents - Hearth and Home Technologies DV3732-B Installation Manual

Safety Alert Key:
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Used to address practices not related to personal injury.
Installation Standard Work Checklist . . . . . . . . . . . . . . . . . . . . 3
1 Product Specific and Important Safety Information
A. Appliance Certification . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
B. Glass Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
C. BTU Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
D. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . . 4
E. Non-Combustible Materials Specification. . . . . . . . . . . . . . 4
F. Combustible Materials Specification . . . . . . . . . . . . . . . . . 4
G. Electrical Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
H. California . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
I. Requirements for the Commonwealth of Massachusetts . . 5
2 Getting Started
A. Design and Installation Considerations . . . . . . . . . . . . . . . 6
B. Good Faith Wall Surface/TV Guidelines . . . . . . . . . . . . . . 6
C. Tools and Supplies Needed . . . . . . . . . . . . . . . . . . . . . . . . 7
D. Inspect Appliance and Components . . . . . . . . . . . . . . . . . . 7
3 Framing and Clearances
A. Appliance/Decorative Front Dimension Diagrams . . . . . . . 8
B. Clearances to Combustibles . . . . . . . . . . . . . . . . . . . . . . 11
C. Constructing the Appliance Chase . . . . . . . . . . . . . . . . . . 13
4 Termination Location and Vent Information
A. Vent Termination Minimum Clearances . . . . . . . . . . . . . . 14

B. Vent Terminal Clearances . . . . . . . . . . . . . . . . . . . . . . . . 15
C. Approved Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
D. Use of Elbows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
E. Measuring Standards . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
F. Use of Flex Vent (SLP-FLEX Series 6-5/8 Inch) . . . . . . . 19
G. Vent Diagrams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
5 Vent Clearances and Framing
A. Pipe Clearances to Combustibles . . . . . . . . . . . . . . . . . . 34
B. Wall Penetration Framing/Firestops . . . . . . . . . . . . . . . . . 35
C. Ceiling Firestop/Floor Penetration Framing . . . . . . . . . . . 36
D. Install Attic Insulation Shield . . . . . . . . . . . . . . . . . . . . . . . 36
6 Appliance Preparation
A. Vent Collar Preparation . . . . . . . . . . . . . . . . . . . . . . . . . . 37
B. Securing and Leveling the Appliance . . . . . . . . . . . . . . . . 40
2 Hearth & Home Technologies • DV3732-B, DV3732L-B, DV4236-B Installation Manual • 2496-980 Rev. M • 10/19

Table of Contents

7 Venting and Chimneys
A. Assemble Vent Sections . . . . . . . . . . . . . . . . . . . . . . . . . 41
B. Assemble Slip Sections . . . . . . . . . . . . . . . . . . . . . . . . . . 42
C. Secure the Vent Sections . . . . . . . . . . . . . . . . . . . . . . . . . 43
D. Disassemble Vent Sections . . . . . . . . . . . . . . . . . . . . . . . 43
E. Vertical Termination Requirements . . . . . . . . . . . . . . . . . . 44
F. Horizontal Termination Requirements . . . . . . . . . . . . . . . 45
8 Electrical Information
A. General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
B. Wiring Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
9 Gas Information
A. Fuel Conversion . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
B. Gas Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
C. Gas Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
D. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . 50
E. Air Shutter Setting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
10 Finishing
A. Facing Material . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
B. Mantel and Wall Projections . . . . . . . . . . . . . . . . . . . . . . . 53
C. Decorative Front Dimensions for Finishing . . . . . . . . . . . 54
11 Appliance Setup
A. Fixed Glass Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
B. Remove the Shipping Materials . . . . . . . . . . . . . . . . . . . 55
C. Clean the Appliance . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
D. Install the Log Assembly. . . . . . . . . . . . . . . . . . . . . . . . . . 56
E. Ember and Lava Rock Placement . . . . . . . . . . . . . . . . . . 58
F. Install Decorative Front/Hood . . . . . . . . . . . . . . . . . . . . . . 59
12 Reference Materials
A. Vent Components Diagrams . . . . . . . . . . . . . . . . . . . . . . 60
B. Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69
 = Contains updated information.