Powerware 5115 RM User Manual
  1. Manuals
  2. Brands
  3. Powerware Manuals
  4. UPS
  5. 5115 RM
  6. User manual

Powerware 5115 RM User Manual

500–1500 va
Hide thumbs Also See for 5115 RM:
Table of Contents

Advertisement

Quick Links

Download this manual
®
Powerware
5115 RM
User's Guide
500–1500 VA
www.powerware.com

Advertisement

Table of Contents
loading

Related Manuals for Powerware 5115 RM

Summary of Contents for Powerware 5115 RM

  • Page 1 ® Powerware 5115 RM User’s Guide 500–1500 VA www.powerware.com...
  • Page 2 Powerware and ABM are registered trademarks and X-Slot and ConnectUPS are trademarks of Powerware Corporation. Copyright 2002-2003 Powerware Corporation, Raleigh, NC, USA. All rights reserved. No part of this document may be reproduced in any way without the express written approval of Powerware Corporation.

  • Page 3: Special Symbols

    Special Symbols The following are examples of symbols used on the UPS to alert you to important information: RISK OF ELECTRIC SHOCK associated warning should be observed. CAUTION: REFER TO OPERATOR’S MANUAL additional information, such as important operating and maintenance instructions.

  • Page 5: Table Of Contents

    ABLE OF 1 Powerware 5115 RM – One of the Best! 2 Safety Warnings ..........
  • Page 6 ..........5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...

  • Page 7: Powerware 5115 Rm - One Of The Best

    The slim design and wide range of installation possibilities make the Powerware 5115 RM the most versatile UPS available. With only 1U (1.75”) of rack-height, the UPS can be installed in rack-mount, wall-mount, side-mount (zero U), and bench-top applications.
  • Page 8 Low voltage models can also protect modems, fax machines, or other telecommunications equipment. Optional X-Slot capabilities for increased power protection and control. The Powerware 5115 RM is backed by worldwide agency approvals. Powerware modules provide enhanced communication 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com...

  • Page 9: Safety Warnings

    UPS must not have an earth leakage current greater than 3.5 milliamperes. Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ® SAVE THESE INSTRUCTIONS D A N G E R W A R N I N G...
  • Page 10 Rumtemperaturen må ikke overstige 40 • C. UPS’en bør ikke betjenes nær vand eller høj fugtighed (maksimalt 95%). Powerware C A U T I O N F A R E A D V A R S E L ! 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...
  • Page 11 UPS aan staat. Hierdoor zou de UPS en uw aangesloten apparatuur geen aardebeveiliging meer hebben. Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ® A D V A R S E L G E V A A R...
  • Page 12 Älä poista tai irrota sisääntulojohtoa, kun UPS on kytkettynä. Tämä poistaa turvamaadoituksen UPS-laitteesta ja siihen liitetystä laitteistosta. Powerware O P G E L E T V A A R A V A R O I T U S 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...
  • Page 13 Ne pas retirer le cordon d’alimentation lorsque l’onduleur est sous tension sous peine de supprimer la mise à la terre de l’onduleur et du matériel connecté. Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ® V A R O D A N G E R !
  • Page 14 Ausgangssteckdosen kann auch dann Spannung anliegen, wenn die USV nicht an einer Wechselspannungsquelle angeschlossen ist. Powerware A T T E N T I O N ! W A R N U N G A C H T U N G 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...
  • Page 15 Öffnen oder beschädigen Sie nicht die Batterien, ausfließendes Elektrolyt ist schädlich für Haut und Augen. Falls Sie die Batterien austauschen, verwenden Sie bitte ausschließlich die gleiche Anzahl und die Batterietypen. Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...
  • Page 16 Safety Warnings ñïåéäïðïéÞóåéò ÁóöÜëåéáò ÇÌÁÍÔÉÊÅ ÏÄÇÃÉÅ Á ÖÁËÅÉÁ ÖÕËÁÎÔÅ ÁÕÔÅ ÔÉ ÏÄÇÃÉÅ ÔÏ ÐÁÑÏÍ ÅÃ×ÅÉÑÉÄÉÏ ÐÅÑÉÅ×ÅÉ ÇÌÁÍÔÉÊÅ ÏÄÇÃÉÅ Á ÖÁËÅÉÁ Powerware ÊÉÍÄÕÍÏ ÐÑÏÅÉÄÏÐÏÉÇ ÇÊ • 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...
  • Page 17 40 • C. Non utilizzare l’unità in prossimità di acqua o in presenza di umidità eccessiva (95% max). Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ® Safety Warnings ÐÑÏ Ï×Ç P E R I C O L O...
  • Page 18 (95% maks.). Powerware A T T E N Z I O N E F A R L I G F A R L I G 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...
  • Page 19 A temperatura ambiente não deve exceder 40 • C. Não opere próximo a água ou em umidade excessiva (máx: 95%). Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ® Safety Warnings F O R S I K T I G C U I D A D O A D V E R T Ê...
  • Page 20 УКАЗАНИЯ ПО МЕРАМ БЕЗОПАСНОСТИ Powerware P E R I G O О П А С Н О П Р Е Д У П Р Е Ж Д Е Н И Е 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...
  • Page 21 Safety Warnings • О С Т О Р О Ж Н О Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...
  • Page 22 SIE no debe tener una intensidad de pérdida a tierra superior a los 3,5 miliamperios. Powerware P E L I G R O A D V E R T E N C I A 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...
  • Page 23 Omgivande temperatur får ej överstiga 40 • C. Använd inte utrustningen nära vatten eller vid hög luftfuktighet (max 95 %). Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ® Safety Warnings P R E C A U C I Ó N...
  • Page 24 Använda batterier får aldrig brännas upp. De kan explodera. Öppna aldrig batterierna eller ta isär dem. Utsläppt elektrolyt är skadlig för hud och ögon och kan vara mycket giftig. Powerware V I K T I G T 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...

  • Page 25: Installation

    UPS. Contact your service representative. UPS Setup The Powerware 5115 RM UPS is designed for flexible configurations and can be installed in a rack, on a wall, or as a standalone cabinet. Set up the UPS according to the type of installation: “Mounting the UPS in a 19”...

  • Page 26: Mounting The Ups In A 19" Rack

    2. On each side of the UPS, attach the long end of a mounting bracket to the UPS using four of the supplied M3 l 6 screws (see Figure 2). Powerware Mounting Bracket 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...
  • Page 27 10. Tighten the assembly wing nuts on both rail assemblies. M6 l 10 Front Rail Screw Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ® Figure 4. Securing the Rear Rail Assembly Wing Nuts Clip Nuts Figure 5. Securing the Front Rail...
  • Page 28 11. After installing the UPS chassis, secure the front of the UPS to the rack using the supplied hardware (one M6 l 10 screw on each side as shown in Figure 6). Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...

  • Page 29: Mounting The Ups In A 23" Rack

    2. On each side of the UPS, attach the short end of a mounting bracket to the UPS using two of the supplied M3 l 6 screws (see Figure 7). Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ® Installation...
  • Page 30 (two M6 l 10 screws and two clip nuts on each side, as shown in Figure 8). Figure 8. Securing the UPS in a 23” Rack Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...

  • Page 31: Zero-U Mounting

    22.54–22.78” or 56.35–56.95 cm). 4. Secure the UPS to the side of the rack cabinet using one M6 l 10 screw and one clip nut in each mounting bracket. Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ® Installation...

  • Page 32: Wall-Mount Setup

    3. Secure the UPS to the wall using one bolt in each mounting bracket as shown. Select the bolt according to the wall type. Wall Figure 10. Mounting the UPS to a Wall Powerware W A R N I N G 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...

  • Page 33: Installing The Ups

    Communication Bay USB Port Site Wiring Fault Indicator 6-ft Power Cord with 5-15 Plug Figure 11. 500–1500 VA, 120V Rear Panel Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ® Four 5-15 Receptacles Protector DIP Switches Communication Port Installation...
  • Page 34 Installation 10A, IEC-320 Input Connector Communication Port Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...

  • Page 35: Operation

    UPS from the power outlet. If you do not unplug the UPS, it remains in Standby mode. Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ® button until you hear , Load 1, and button for two seconds and...

  • Page 36: Standby Mode

    “Troubleshooting” on page 47. Powerware Service Indicator (Red) Power On Indicator (Green) Overload Indicator (Red) Figure 13. UPS Front Panel button for three seconds to initiate the self-test. If 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ® On/Off Button Test/Alarm Reset Button...

  • Page 37: Additional Ups Features

    3. Plug the UPS into a power outlet. 4. Press and hold the (approximately two seconds) to turn the UPS on. Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ® EATURES button until you hear the UPS beep UPS Rear Panel Figure 14.

  • Page 38: Network Transient Protector

    Input Voltage Range DIP Switch 1 99V-116V 108V–127V* 230V Models Input Voltage Range DIP Switch 1 198V–233V 207V–243V* 216V–254V Figure 15. Network Transient Protector 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ® DIP Switch 2 OFF/ON OFF/ON DIP Switch 2 OFF/ON...

  • Page 39: Load Segments

    Figure 17. The Load 1 and Load 2 indicators on the UPS front panel illuminate when output power is available to the specific load segment. Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ® Load Segment 1 Figure 16. UPS Load Segments for 120V Models...
  • Page 40 Additional UPS Features Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...

  • Page 41: Communication

    C H A P T E R 6 OMMUNICATION The Powerware 5115 RM has flexible communication options for local, network, or remote monitoring and management. You can use the USB port or the DB-9 communication port to connect your computer to the UPS.

  • Page 42: Communication Port

    To external device (tied to Pin 4) No Connection AC Fail relay contact; 20 mA, 30 Vdc contact rating +V (8 to 24 volts DC power) 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ® Direction from the UPS — —...

  • Page 43: X-Slot Cards

    X-Slot Cards X-Slot cards allow the UPS to communicate in a variety of networking environments and with different types of devices. The Powerware 5115 RM is compatible with any X-Slot card, including: ConnectUPS -X Web/SNMP Card - has SNMP and HTTP capabilities as well as monitoring through a Web browser interface;...
  • Page 44 Communication Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...

  • Page 45: Ups Maintenance

    Check the battery recharge date on the shipping carton label. If the date has expired and the batteries were never recharged, do not use the UPS. Contact your service representative. Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...

  • Page 46: Replacing Batteries

    1. Pull the left side of the front panel to release the snaps to the left and middle of the panel. Remove the front panel from the right side. Powerware W A R N I N G C A U T I O N 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...
  • Page 47 “Recycling the Used Battery” on page 42 for proper disposal. 5. Slide the new battery group into the UPS. 6. Reinstall the battery cover removed in Step 3. 7. Reconnect the white battery connector. 8. Reinstall the front panel. Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...

  • Page 48: Testing New Batteries

    Load indicators. indicator flashes. Check the battery connections W A R N I N G C A U T I O N 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®  indicator...

  • Page 49: Specifications

    C H A P T E R 8 PECIFICATIONS This section provides the following specifications for the Powerware 5115 RM models: Dimensions and weights Electrical input and output Environmental and safety Battery Table 3. Model List and Mechanical 120V Models...
  • Page 50 UL 1778, UL 497A (data line only); CSA C22.2, No. 107.1; EN 50091-1-1 and IEC 60950 UL, cUL EN 50091-2, FCC Part 15, ICES-003 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ® 230V Models 500 VA, 320W 750 VA, 520W 1000 VA, 670W...
  • Page 51 Advanced monitoring for earlier failure detection and warning Battery Run Times 5 minutes, typical at full load Battery times are approximate and may vary depending on the load configuration and battery charge. Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ® Specifications...
  • Page 52 Specifications Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...

  • Page 53: Troubleshooting

    Audible Alarms and UPS Conditions The UPS has an audible alarm feature to alert you of potential power problems. Use Table 8 to determine and resolve the UPS alarms and conditions. Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...

  • Page 54: Silencing An Audible Alarm

    None. The UPS is operating in Normal mode and automatically provides consistent voltage with the Buck and Boost feature. Power is available to the load segments as indicated by Load 1 (Yellow) and Load 2 (Green). 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...
  • Page 55 Continuous beep. UPS internal temperature is too high. Continuous beep. Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ® Troubleshooting Action The UPS is powering your equipment with battery power. Prepare your equipment for shutdown. If this is an extended power outage, save your work and turn off your equipment to conserve battery power.
  • Page 56 The alarm cannot be silenced. Save your work and turn off your equipment. Turn off and unplug the UPS. Contact your service representative. The alarm cannot be silenced. 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...

  • Page 57: Service And Support

    NOTE For critical applications, immediate replacement may be available. Call the for the dealer or distributor nearest you. Help Desk Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ® at one of the following telephone numbers Help Desk 1-800-356-5737...
  • Page 58 Troubleshooting Powerware 5115 Rack-Mount User’s Guide 164201449 Rev A www.powerware.com ®...

Table of Contents