Table of Contents
Advertisement
Owner's Installation
On Demand Pilot Light (seven day safety timer) .....................4
Safety Label .............................................................................5
Copy of Safety Decal ...............................................................5
Decal location ..........................................................................5
Unit Dimensions ......................................................................6
4 sided faceplate Dimensions ..................................................6
Important Message ................................................................9
Before You Start .......................................................................9
General Safety Information ......................................................9
Lighting Procedure ................................................................10
Copy of Lighting Plate Instructions ........................................11
Proflame I Remote Control Operating Instructions ................12
Warranty ................................................................................68
Installer's Installation
Gas Installation Checklist ..............................................7
Checklist ............................................................16
Locating your Fireplace .........................................................16
Duct System Option ...............................................................16
MA Code - CO Detector ........................................................17
Clearances ............................................................................18
Combustible Mantels .............................................................19
Mantel Leg Clearances .........................................................20
Framing Dimensions ..............................................................21
Framing & Finishing ...............................................................22
Tile - Stone - Brick - Mantel - Surround Finish ..............22
Non-Combustible Board Only (Painted Finish) .............23
Venting Introduction ...............................................................24
Exterior Vent Termination Locations ......................................25
®
Direct Vent flex System ........................................26
Installation Procedures ..........................................................27
Rigid Pipe Venting Systems ...................................................28
4" x 6-5/8" Rigid Pipe Cross Reference Chart .......................29
Rigid Pipe Venting Arrangements .........................................31
Vertical Termination with Co-Linear Flex System ..................37
On Demand Pilot Light
Important information if using the appliance in CPI (continuous pilot mode) only.
This appliance is a ProFlame 1 system fitted with the "On Demand" Pilot, a safety feature which will shut down the gas valve completely by extinguishing
the pilot light in the event of a continuous full seven days of inactivity.
This only applies if the CPI (continuous pilot) switch is in the "on" position.
Each time the main burner shuts down, manually or through the call from the thermostat, the seven day timer starts again.
The seven day inactivity timer is controlled within the circuit board. Therefore, if in CPI mode and when the pilot light is extinguished after seven straight
days of inactivity, the IPI/CPI rocker switch will remain in the "on" position. Therefore, all that is required to relight the pilot would be to press the on/off
button on the remote control transmitter from "on" to "off" and back to "on". Once the pilot has re-established operation will resume as normal. There is no
requirement to do anything with the IPI/CPI rocker switch.
If the unit never goes as long as seven full days without a call for heat, the pilot will remain lit until it is manually shut-off.
If the unit is being operated in IPI (intermittent pilot) mode, neither the above instructions nor the seven day timer will apply.
See the instructions in this manual and on the Lighting Instructions plate on the appliance to light or re-light the pilot.
|
4
P33CE-11 Direct Vent Gas Fireplace
(seven day safety timer)
Venting Arrangements - Vertical Terminations ......................38
Unit installation with Horizontal termination ...........................39
Unit installation with Vertical Termination ...............................40
Gas Line Installation ..............................................................40
Vertical Flue Extension Kit (part #946-756) ...........................42
Ceiling Firestop / Firestop Spacer (part #946-757) ...............42
Pilot Adjustment .....................................................................43
High Elevation ........................................................................43
885 S.I.T. Valve Description ...................................................43
Gas Pipe Pressure Testing ....................................................43
Conversion from NG to LP.....................................................44
Optional Enamel Panels ........................................................45
Optional Brick Panels ............................................................46
Log Set Installation ................................................................46
Optional Birch Log Set Installation ........................................48
Glass Door and Safety Screen Installation ............................50
Standard Flush Door .............................................................50
Safety Screen ........................................................................50
Optional 4-sided Faceplate Installation ..................................51
Wiring Diagram ......................................................................52
Optional Wall Thermostat Installation ....................................53
Installing the Optional Fan ....................................................54
Wiring Diagram with Optional Fan .........................................57
Operating Instructions ...........................................................58
First Fire ................................................................................58
Aeration Adjustment ..............................................................58
Lighting Procedure ................................................................59
Shutdown Procedure .............................................................59
Copy of the Lighting Plate Instructions ..................................60
Maintenance Instructions.......................................................61
General Vent Maintenance ....................................................61
Log Replacement ..................................................................61
Normal Operating Sounds of Gas Appliances .......................61
Glass Gasket .........................................................................62
Door Glass .............................................................................62
Removing Valve .....................................................................63
Installing Valve .......................................................................63
Gas Appliance Maintenance ..................................................64
Main Assembly ......................................................................65
Burner & Log Assembly .........................................................66
Warranty ...............................................................................68
Advertisement
Table of Contents
