Chapter 3 - Unit Preparations; Handling Instructions; Wall Mounting Installation; Accessories - IDEAL EXALT Solo 110 Installation & Maintenance Manual

CHAPTER 3 - UNIT PREPARATIONS

3.1.

Handling Instructions

The EXALT is generally easier to handle and maneuver
once removed from the shipping carton.
To remove the shipping carton:
NOTICE
Use care not to drop, bump or rotate the boiler
upside down, as damage to the boiler will result.
1. Remove any shipping straps.
2. Slide the cardboard sleeve from the unit.
3. Remove the wall mounting template.
4. Remove the accessory boxes.
5. Remove upper and lower cardboard end pieces.
6. Remove the boiler from the cardboard tray.
7. Discard all packing materials and recycle where
possible.
The Exalt is supplied with an acoustic dampening
foam insert located in the appliance air inlet. DO NOT
remove this on any installation. The LP foam (110 and
155 models only) is to be installed in addition to the
preinstalled foam when converting to Propane.
LP Venturi Auto Air Vent
3/4" Elbow Reduced Tee
Outdoor
Sensor
LP Foam
110, 155 only
3.2.
The EXALT should be wall mounted using the wall
mounting template and bracket provided with the
boiler. The EXALT is not designed for floor installation.
The EXALT is not to be installed on carpeting
The wall used for mounting the EXALT must be
vertically plumb and capable of supporting at
•
•
•
•
•
Note. All weights above include EXALT water
Failure to comply with these requirements can
result in substantial property damage, serious
3.3.
Unpack and check the the list of all accessories as
shown in Fig. 5 below.
3/8" NPT temperature Bird Screens (x2)
and pressure gauge
Union Screws (x4) / Anchors (x4)

Fig. 5 - Accessories

Wall Mounting Installation

WARNING
minimum:
119.5 pounds [54 kg] for the EXALT Solo 110
141 pounds [64 kg] for the EXALT Solo 155
158 pounds [71.5 kg] for EXALT Solo 199
165 pounds [75 kg] for EXALT Combi 155
183 pounds [83 kg] for EXALT Combi 199
volumes.
injury, or death.

Accessories

Pressure Relief Valve
Gas Pipe Gaskets (x2)
DHW sensor,
solo models
only
13