Yanmar 3TNV82A Service Manual page 31

Safety Precautions
CAUTION
• When the engine is operated in dusty
conditions, clean the air cleaner
element more frequently.
• NEVER operate the engine with the air
cleaner element(s) removed. This may
allow foreign material to enter the
engine and damage it.
CAUTION
The maximum air intake restriction, in
terms of differential pressure
measurement, must not exceed 0.90 psi
(6.23 kPa; 635 mmAq). Clean or replace
the air cleaner element if the air intake
restriction exceeds the above
mentioned value.
CAUTION
It is important to perform daily checks.
Periodic maintenance prevents
unexpected downtime, reduces the
number of accidents due to poor
machine performance and helps extend
the life of the engine.
CAUTION
If the oil pump must be replaced, replace
it as an assembly only. Do not replace
individual components.
TNV DI Service Manual
Do not loosen or remove the four bolts
retaining the fuel injection pump drive
gear to the fuel injection pump hub. Do
not disassemble the fuel injection pump
drive gear from the hub. Correct fuel
injection timing will be very difficult or
impossible to achieve.
0000026en
The starter motor can be damaged if
operated continuously longer than
10 seconds while performing the
no-load test.
0000046en
Do not short-circuit the charging system
between alternator terminals IG and L.
Damage to the alternator will result.
Do not connect a load between
alternator terminals L and E. Damage to
the alternator will result.
0000060en
Do not remove the positive (+) battery
cable from alternator terminal B while
the engine is operating. Damage to the
alternator will result.
0000030en
Do not turn the battery switch OFF while
the engine is operating. Damage to the
alternator will result.
SAFETY
CAUTION
0000031en
CAUTION
0000034en
CAUTION
0000035en
CAUTION
0000036en
CAUTION
0000037en
CAUTION
0000038en
3-17