Storage - Toro workman HDX-D 07368 Operator's Manual

Storage

1. Position the machine on a level surface, set the
parking brake, stop the engine, and remove the
ignition key.
2. Clean dirt and grime from the entire machine,
including the outside of the engine cylinder head fins
and blower housing.
Important: You can wash the machine with
mild detergent and water. Do not use high
pressure water to wash the machine. Pressure
washing may damage the electrical system or
wash away necessary grease at friction points.
Avoid excessive use of water, especially near the
control panel, lights, engine, and the battery.
3. Inspect the brakes; refer to Inspecting the Brakes.
4. Service the air cleaner; refer to Servicing the Air
Cleaner.
5. Seal the air cleaner inlet and the exhaust outlet with
weatherproof tape.
6. Grease the machine.
7. Change the engine oil; refer to Changing the Engine
Oil and Filter.
8. Flush the fuel tank with fresh, clean diesel fuel.
9. Secure all fuel system fittings.
10. Check the tire pressure; refer to Checking the Tire
Pressure.
11. Check anti freeze protection and add a 50/50
solution of water and anti freeze as needed for
expected minimum temperature in your area.
12. Remove the battery from the chassis, check the
electrolyte level, and charge it fully; refer to Servicing
the Battery.
Note: Do not connect the battery cables to the
battery posts during storage.
Important: The battery must be fully charged
to prevent it from freezing and being damaged
at temperatures below 32°F (0°C). A fully
charged battery maintains its charge for about
50 days at temperatures lower than 40°F (4°C).
If the temperatures will be above 40°F (4°C),
check the water level in the battery and charge it
every 30 days.
13. Check and tighten all bolts, nuts, and screws. Repair
or replace any part that is damaged.
14. Paint all scratched or bare metal surfaces.
Paint is available from your Authorized Service
Dealer.
15. Store the machine in a clean, dry garage or storage
area.
16. Remove the ignition key and put it in a safe place out
of the reach of children.
17. Cover the machine to protect it and keep it clean.
57