Troubleshooting (Engine) - MULTIQUIP TLG8SSK4F Operation And Parts Manual

SYMPTOM
Engine does not start.
Starter does not run.
PAGE 58 — TLG8SSK4F PORTABLE GENERATOR• OPERATION AND PARTS MANUAL — REV. #0 06/21/16)

TROUBLESHOOTING (ENGINE)

Table 13. Engine Troubleshooting
POSSIBLE PROBLEM
No fuel?
Air in the fuel system?
Water in the fuel system?
Fuel pipe clogged?
Fuel filter clogged?
Excessively high viscosity of fuel or
engine oil at low temperature?
Fuel with low cetane number?
Fuel leak due to loose injection pipe
retaining nut?
Incorrect injection timing?
Fuel cam shaft worn?
Injection nozzle clogged?
Injection pump malfunctioning?
Seizure of crankshaft, camshaft, piston,
cylinder liner or bearing?
Compression leak from cylinder?
Improper valve timing?
Piston ring and liner worn?
Excessive valve clearance?
Battery discharged?
Starter malfunctioning?
Key switch malfunctioning?
Wiring disconnected?
SOLUTION
Replenish fuel.
Bleed system.
Remove water from fuel tank.
Clean fuel pipe.
Clean or change fuel filter.
Use the specified fuel or engine oil.
Use the specified fuel.
Tighten nut.
Adjust.
Replace.
Clean injection nozzle.
Repair or replace.
Repair or replace.
Replace head gasket, tighten cylinder
head bolt, glow plug and nozzle holder.
Correct or replace timing gear.
Replace.
Adjust.
Charge battery.
Repair or replace.
Repair or replace.
Connect wiring.