Table Of Contents - Jøtul GF 500 DV IPI Installation And Operation Instructions Manual

Table of Contents

Service Tools ............................................. 2
Specifications ............................................4
Initial Assembly ........................................ 5
Rear Exit Vent Conversion ............................... 6
General Information ................................ 7
Safety Information .................................. 7
Installation Requirements .....................8
Location .............................................................. 8
Floor Protection ................................................. 8
Clearances .......................................................... 8
Alcove .................................................................. 8
Mantel & Trim .................................................... 9
Venting Requirements .....................................10
Vent Restriction .................................................10
Termination Matrix ...........................................11
Vertical Termination ......................................... 12
Horizontal Termination ...................................14
Vent Terminal Clearances ..............................16
f i r e - p a r t s . c o m
Fuel Conversion ........................................17
Gas Connection ...................................... 20
Gas Pressure ............................................ 21
High Altitude Adjustment ................... 21
Optional Brick Panel Installation .......22
Optional Wall Thermostat ....................22
Premium Upgrade Kits
Flame Control ...................................................23
Accent Lamp .....................................................23
Blower .............................................................. 24
Log Set Installation ................................25
System Check ........................................ 26
Flame Picture Adjustment ...................27
Operation Guidelines ............................28
Manual Operation ............................................ 29
Remote Control .......................................... 30-34
Maintenance ........................................... 35
Glass Replacement ............................................35
Battery Replacement - Transmitter .............. 35
Battery Replacement - IFC ........................... 36
Appendix
Wiring Diagram .................................................37
Illustrated Parts Lists .................................38-40
Accessory Listing ............................................. 40
Mobile Home Requirements ..........................41
Warranty Statement ..............................42
Lighting Instructions .............................43
139636_02 GF 500 DV IPI January 2015
Jøtul GF 500 DV IPI
Portland
Direct Vent Gas Heater
Manufactured and Distributed by:
Jøtul North America
55 Hutcherson Dr.
Gorham, Maine 04038
Certified Test Standards
This appliance complies with National Safety
standards and is tested and listed by Intertek Testing
Services of Middleton, Wisconsin to ANSI Z21.88-2014,
CSA 2.33-2014, CAN/CGA 2.17-M91, and CSA P.4-01.2
WARNING:
READ AND UNDERSTAND ALL OPERATING
INSTRUCTIONS BEFORE ATTEMPTING TO OPERATE
THIS APPLIANCE. DO NOT ALLOW ANYONE TO
OPERATE THIS APPLIANCE WHO HAS NOT READ
AND UNDERSTOOD THESE INSTRUCTIONS. KEEP
THE REMOTE CONTROL TRANSMITTER WHERE
CHILDREN CANNOT REACH IT.
WARNING:
SEVERE INJURY. THIS APPLIANCE CAN BE SET TO
OPERATE THERMOSTATICALLY. BE AWARE THAT
THE FIREPLACE MAY BE VERY HOT EVEN WHEN
THE BURNER IS NOT APPARENTLY OPERATING.
KEEP CHILDREN AWAY FROM THE APPLIANCE.
WARNING:
FIRE HAZARD. CAN CAUSE SEVERE INJURY
OR DEATH. THE APPLIANCE CAN TURN ON
SUDDENLY. KEEP AWAY FROM THE APPLIANCE
BURNER WHEN OPERATING THE REMOTE
SYSTEM.
3