ECR International Dunkirk DCBF-165 Manuals

Manuals and User Guides for ECR International Dunkirk DCBF-165. We have 2 ECR International Dunkirk DCBF-165 manuals available for free PDF download: Manual, Installation, Operation And Maintenance Manual

ECR International Dunkirk DCBF-165 Manual (139 pages)

CONDENSING GAS FIRED BOILER

Brand: ECR International | Category: Boiler | Size: 41 MB

Section 1

7
- Verify Contents Received
  6
  - Table of Contents
    7
- Physical Data
  8
- Important Information
  11
- Introduction
  12
- Requirements for Commonwealth of Massachusetts
  12
- Designated Use
  12
- The Unit Must Not
  12
- Operational Features
  12
- Component Listing
  13
- Locating Boiler
  19
- Boiler Location Considerations
  19
- Floor Location
  19
- Clearances
  20
- Combustion Air and Vent Piping
  21
- General
  21
- Removal of Existing Boiler from Common Vent System
  22
- Definitions
  22
- Vent Termination
  23
- Approved Venting Materials
  23
- Coaxial Venting Instructions
  25
- Coaxial Vent Screw Placement
  26
- Twin Pipe Systems
  27
- Twin Pipe Polypropylene Adapter Kit Installation
  28
- Twin Pipe Cpvc Adapter Kit Installation
  29
- Securing Twin Pipe Polypropylene Venting
  30
- Flexible Vent System
  33
- Condensate Piping
  35
- Special Conditions
  36
- Hydronic Piping
  36
- General
  36
- Safety Relief Valve and Air Vent
  37
- Trim Piping
  37
- System Piping
  37
- External Optional Low Water Cut off
  39
- Manufacturer Recommendation - Strainer
  40
- Pump Protection
  41
- Central Heating System
  41
- Frost Protection Mode
  41
- Gas Supply Piping
  42
- General
  42
- Gas Pipe Recommendations
  43
- Leak Check Gas Piping
  45
- Gas Orifice
  45
- Electrical Connections
  46
- General
  46
- Electrical Connections
  47
- Access to Connection Block
  47
- Main Supply Connection
  47
- Install Room Thermostat
  48
- Outdoor Air Sensor (OAS) Electrical Connections
  48
- Indirect Storage Tank
  50
- Management of 0-10V Input
  50
- Central Heating System Connections - Combi
  52
- Start up Procedure
  52
- System Start up
  53
- Fill Condensate Trap with Water
  53
- Control Panel
  54
- Prior to Commissioning
  55
- Commissioning for the First Time
  55
- Automatic Calibration Function
  55
- Changing the Type of Gas
  56
- Aeration Function
  56
- Manual Calibration Function
  56
- Chimney Sweep Function
  57
- Combustion Adjustment Function (CO2%)
  57
- Check Firing Rate
  58
- Parameter Settings
  58
- Description of Parameters: Factory Settings
  59
- Adjusting Maximum Heating Power
  61
- Central Heating Mode
  62
- Testing for Gas Leaks and Purging Gas Supply
  62
- Boiler Operation
  62
- Operating Instructions
  62
- Domestic Hot Water Mode
  63
- Frost Protection
  63
- Pump
  63
- Low Water Pressure Sensor (Internal)
  63
- General Maintenance and Cleaning
  64
- Beginning of each Heating Season
  64
- Maintenance and Routine Servicing
  65
- Component Replacement and Cleaning
  65
- Draining the Boiler
  66
- Draining the Heating Circuit
  66
- Hydraulic Unit (DHW)
  67
- Cleaning the Cold Water Filter
  67
- Final Commissioning
  67
- Final Assembly
  67
- Replacement Parts
  68
- Safety Flue Thermostat
  68
- Flue Pressure Switch
  68
- User Information
  68
- Ratings and Capacities
  69
- Ratings and Capacity
  69
- Domestic Hot Water Specifications
  69
- High Altitude Ratings
  70
- High Altitude Chart
  70
- Available Boiler Pump Head
  71
- Trouble Shooting
  72
- Error Messages and Resetting the Boiler
  72
- Anomalies Table for the Installer - Use this Table to Report the Anomaly Values
  74
- Glossary
  75
- Appendix A - Wiring Diagrams
  77
Section 2

86

ECR International Dunkirk DCBF-165 Installation, Operation And Maintenance Manual (118 pages)

CONDENSING GAS FIRED BOILER

Brand: ECR International | Category: Boiler | Size: 10 MB

Section 1

5
- Verify Contents Received
  4
  - Table of Contents
    5
- Important Information
  6
- Physical Data
  7
- Component Listing
  10
- Introduction
  14
- Locating Boiler
  15
- Combustion Air and Vent Piping
  17
- General
  17
- Removal of Existing Boiler from Common Vent System
  17
- Definitions
  18
- Approved Venting Materials
  19
- Vent Termination
  19
- Coaxial Venting Instructions
  20
- Coaxial Vent Screw Placement
  20
- Twin Pipe Systems
  22
- Securing Twin Pipe Polypropylene Venting
  23
- 3" /80 MM Only) Flexible Vent System
  26
- Condensate Piping
  28
- Hydronic Piping
  29
- General
  29
- Special Conditions
  29
- Safety Relief Valve and Air Vent
  30
- Trim Piping
  30
- System Piping
  30
- External Optional Low Water Cut off
  32
- Central Heating System
  34
- Domestic Hot Water Mode
  34
- Frost Protection Mode
  34
- Pump Protection
  34
- General
  35
- Gas Supply Piping
  35
- Leak Check Gas Piping
  36
- Gas Orifice
  36
- Electrical Connections
  37
- General
  37
- Install Room Thermostat
  37
- Electrical Connections
  38
- Access to Connection Block
  38
- Main Supply Connection
  38
- Optional Electrical Connections
  39
- Indirect Storage Tank
  40
- Management of 0-10V Input
  40
- Start up Procedure
  41
- Central Heating System Connections - Heat Only
  41
- Central Heating System Connections - Combi
  41
- System Start up
  42
- Fill Condensate Trap with Water
  42
- Control Panel
  43
- Prior to Commissioning
  44
- Commissioning for the First Time
  44
- Automatic Calibration Function
  44
- Manual Calibration Function
  45
- Aeration Function
  45
- Commission Set up (Gas) - Changing the Type of Gas
  45
- Chimney Sweep Function
  46
- Adjust)
  46
- Combustion Adjustment Function
  46
- Check Firing Rate
  46
- Description of Parameters: Factory Settings
  47
- Parameter Settings
  47
- Description of Parameters: Factory Settings Conti
  48
- Adjusting Maximum Heating Power
  49
- Operating Instructions
  50
- Testing for Gas Leaks and Purging the Gas Supply
  50
- Boiler Operation
  50
- Central Heating Mode
  50
- Domestic Hot Water Mode
  50
- Frost Protection
  50
- Pump
  50
- Low Water Pressure Sensor (Internal)
  50
- General Maintenance and Cleaning
  51
- Beginning of each Heating Season
  51
- Maintenance and Routine Servicing
  52
- Component Replacement and Cleaning
  52
- Draining the Boiler
  53
- Draining the Heating Circuit
  53
- Final Assembly
  54
- Cleaning the Cold Water Filter
  54
- Final Commissioning
  54
- Hydraulic Unit (DHW)
  54
- User Information
  55
- Safety Flue Thermostat - DO NOT Disable this Safety Device
  55
- Replacement Parts
  55
- Ratings and Capacities
  56
- Ratings and Capacity
  56
- Domestic Hot Water Specifications
  56
- High Altitude Ratings
  57
- High Altitude Chart
  57
- Trouble Shooting
  58
- Error Messages and Resetting the Boiler
  58
- Anomalies Table for the Installer - Use this Table to Report the Anomaly Values
  60
- Glossary
  61
- Appendix A - Wiring Diagrams
  63
- Check out Certificate
  69
Section 2

72

ECR International Categories

Boiler Furnace

Air Conditioner Heat Pump Water Heater

More ECR International Manuals

ECR International Dunkirk DCBF-165 Manuals

ECR International Dunkirk DCBF-165 Manual (139 pages)

Table of Contents

Section 1

Section 2

ECR International Dunkirk DCBF-165 Installation, Operation And Maintenance Manual (118 pages)

Table of Contents

Section 1

Section 2

Related Products

ECR International Categories