Table Of Contents - Chamberlain LIFTMASTER PROFESSIONAL MSLDCBB Installation And Service Manual

T A B L E O F C O N T E N T S
INTRODUCTION
Installation Check Off List . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
What to Expect and Gate Operator Classes . . . . . . . . . . . . . . .4
Recommended Site Layout . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Safety Recommendations . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Unit Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Pre-Installation Notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
INSTALLATION
Concrete Pad . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
Anchors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
Conduits . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
Chain Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
Safety Edge Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
WIRING AND HOOKUP
120 Volts AC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
Input Commands 1-8 (3-Button Control Station) . . . . . . . . . .9
Accessory and Relay Connections . . . . . . . . . . . . . . . . . . . . .10
Battery Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10
Master/Second Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10
TIMERS AND MODE SELECTIONS S1 & S2
Full Speed Run Timer - S1 . . . . . . . . . . . . . . . . . . . . . . . . . . .11
Mode Selections - S1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
Close Timer - S2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
Mode Selections - S2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
ADJUSTMENTS
Right or Left Hand Operation . . . . . . . . . . . . . . . . . . . . . . . . .12
Limit Switch Adjustments . . . . . . . . . . . . . . . . . . . . . . . . . . .12
Instant Reverse Device (IRD) . . . . . . . . . . . . . . . . . . . . . . . .12
INSTALL THE RECEIVER
Wiring the Receiver . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13
Set Security Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13
Programming the Remote to the Receiver . . . . . . . . . . . . . .13
To Erase All Remote Control Codes . . . . . . . . . . . . . . . . . . . .13
OPERATION
Manual Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14
MAINTENANCE
General Service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14
TROUBLESHOOTING AND MAINTENANCE
Battery Checkout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14
Gate Not Operating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14
SUGGESTED ENTRAPMENT PROTECTION DEVICE LOCATIONS
Free Exit on Vehicle Approach . . . . . . . . . . . . . . . . . . . . . . . .15
Entry With Access Control Device . . . . . . . . . . . . . . . . . . . . .15
Dual Direction as Entry and Free Exit . . . . . . . . . . . . . . . . . .15
CONTROL BOARD LAYOUT
Component Locations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16
MEGA SLIDE UL PARTS LIST
Part Numbers and Descriptions . . . . . . . . . . . . . . . . . . . . . . .17
Parts Shipped . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17
OPERATOR NOTES
WARRANTY
REPAIR PARTS AND SERVICE
I N T R O D U C T I O N
IMPORTANT SAFETY INSTRUCTIONS
WARNING - To reduce the risk of SERIOUS INJURY or DEATH:
1. READ AND FOLLOW ALL INSTRUCTIONS.
2. Never let children operate or play with gate controls. Keep
the remote control away from children.
3. Always keep people and objects away from the gate. NO ONE
SHOULD CROSS THE PATH OF THE MOVING GATE.
4. Test the gate operator monthly. The gate MUST reverse on
contact with a rigid object or stop when an object activates
the non-contact sensors. After adjusting the force or the limit
of travel, retest the gate operator. Failure to adjust and retest
the gate operator properly can increase the risk of injury or
death.
5. Use the emergency release only when the gate is not
moving.
6. KEEP GATES PROPERLY MAINTAINED. Read the owner's
manual. Have a qualified service person make repairs to gate
hardware.
7. The entrance is for vehicles only. Pedestrians must use
separate entrance.
8. SAVE THESE INSTRUCTIONS.
WARNING! Children should never be allowed to play near or
operate automatic gates. Failure to observe safe operating
procedure, train your customer properly, or install proper
warning signage may result in serious injury.
18
19
20
2