Formula Fastech Service Manual page 110

FASTECH
Symptom
Engine will not crank
Engine cranks but
will not start
Low starter speed
Engine runs erratically
Engine vibrates
Engine runs but boat
makes little or no
progress
Performance Loss
Lack of power
Hard shifting
11-2
Possible Cause
Lanyard – install on ignition safety switch.
Battery switch – turn to ON position.
Shift position – check to see that lever is in start or NEUTRAL position.
Battery condition – battery must be fully charged.
Starter connections – check connections and tighten. If solenoid clicks
when attempting to start engine, check battery connections. If condition
persists, see your Formula dealer.
Engine circuit breaker – breaker must be in operating position.
Faulty ignition switch – see Formula dealer.
Engine problem – see your Formula dealer.
Contaminated fuel – see Formula dealer.
Engine problem – see Formula dealer.
Weak or bad battery – see Formula dealer.
See your Formula dealer.
Propeller condition – shut off engine. Check for bent, broken or damaged
propeller. Check for weeds on propeller.
Engine problem – see Formula dealer.
Fouled or damaged propeller – shut off engine. Check for weeds on
propeller, bent or broken propeller. See your Formula dealer.
Throttles not fully open – check to see that throttles open fully at
engines.
Improper fuel – fill tanks with correct fuel.
Overheating – immediately turn OFF the engines and contact your Formula
dealer.
Boat overloaded – reduce load.
Boat trim – distribute boat load evenly.
Improper propeller selection – see Formula dealer.
Excessive bilge water – check for excessive water, drain bilge.
Boat hull condition – clean if marine growth is present.
Throttle not fully open – adjust throttle linkage.
Contaminated fuel – drain fuel tank and lines. Flush with clean fuel and
replace fuel filters.
Corroded or pinched linkage.
FASTECH FORMULA