Page 1
XR-C2600 3 7 63 1515 0 SERVICE MANUAL E Model Model Name Using Similar Mechanism XR-1100 Tape Transport Mechanism Type MG-36SZ10-32 SPECIFICATIONS Cassette player section Power amplifier section Tape track 4-track 2-channel stereo L 13942296513 Outputs Speaker outputs Wow and flutter 0.13 % (WRMS)
http://www.xiaoyu163.com 3 7 63 1515 0 TABLE OF CONTENTS Flexible Circuit Board Repairing • Keep the temperature of the soldering iron around 270 ˚C dur- ing repairing. GENERAL • Do not touch the soldering iron on the same conductor of the Location of Controls ............
-SEEK/AMS 1 Press (ENTER). SOUND ENTER SHUF RELEASE XR-C2600 The hour indication flashes. 2 Press either side of (PRST/DISC) to set the hour. Refer to the pages listed for details. 3 Press + side of (SEEK/AMS). 1 MENU button 7, 9, 10, 11, 13 qd SEEK/AMS –/+ (cursor left/right) buttons...
http://www.xiaoyu163.com SECTION 2 DISASSEMBLY 3 7 63 1515 0 Note: Follow the disassembly procedure in the numerical order given. SUB PANEL 1 three claws 1 two claws 2 sub panel L 13942296513 MECHANISM DECK (MG-36SZ10-32) 2 two screws 2 two screws (BTP2.6 ×...
Page 8
http://www.xiaoyu163.com 3 7 63 1515 0 MAIN BOARD 3 two screws 2 two ground point screws (BTP2.6 × 6) 4 main board 3 screw (BTP2.6 × 6) 1 claw L 13942296513 BRACKET (MD) 1 claw 1 claw 3 bracket (MD) u163 1 claw 2 four screws...
Page 9
http://www.xiaoyu163.com 3 7 63 1515 0 HEAT SINK 1 seven screws (BTP2.6 × 10) 2 hear sink L 13942296513 MOTOR ASS’Y (CAPSTAN/REEL) (M901) 2 main belt 3 sub belt (C) 1 two screws (P2 × 2.5) 4 motor ass’y (capstan/reel) (M901) Note: When installing motor, u163...
http://www.xiaoyu163.com SECTION 3 SECTION 4 MECHANICAL ADJUSTMENTS ELECTRICAL ADJUSTMENTS 3 7 63 1515 0 TEST MODE 1. Clean the following parts with a denatured-alcohol-moistened swab: This set have the test mode function. In the test mode, FM Auto playback head pinch roller Seek/Stop Level and AM Auto Seek/Stop Level Check can be per- rubber belt...
Page 11
http://www.xiaoyu163.com 3 7 63 1515 0 Tape Speed Adjustment 3. Check the phase in the FWD PB mode. Setting: test tape speed checker P-4-A063 (6.3 kHz, –10 dB) oscilloscope frequency counter test tape 10 k Ω L-CH WS-48A (3 kHz, 0 dB) 10 kΩ...
http://www.xiaoyu163.com 3 7 63 1515 0 Procedure: TUNER SECTION 0 dB=1 µV FM Stereo Level meter Level meter signal generator connection reading (dB) Cautions during repair output channel When the tuner unit is defective, replace it by a new one be- L-CH L-CH cause its internal block is difficult to repair.
Page 13
http://www.xiaoyu163.com 3 7 63 1515 0 Adjustment Location: – SET UPPER VIEW – Tape Speed Adjustment TU100 RV2 FM Auto Seek/Stop Level Adjustment – TU100 (Component Side) – L 13942296513 RV1 FM Stereo Separation Adjustment u163 http://www.xiaoyu163.com...
Front panel block remove/attach detection signal input terminal NOSE-SW “L”: front panel is attached, “H”: front panel is removed Battery detection signal input from the SONY bus interface (IC800) and battery detect circuit BU-IN “L” is input at low voltage —...
Page 22
— Not used (open) SYS-RST Reset signal output to the SONY bus interface (IC800) “L”: reset BUS-ON Bus on/off control signal output to the SONY bus interface (IC800) “L”: bus on 62 to 67 — Not used (open) L 13942296513 Main system power supply on/off control signal output terminal “H”: power on...
http://www.xiaoyu163.com SECTION 6 EXPLODED VIEWS 3 7 63 1515 0 NOTE: • Items marked “*” are not stocked since they • -XX and -X mean standardized parts, so they may have some difference from the original are seldom required for routine service. Some one.
http://www.xiaoyu163.com SECTION 7 3 7 63 1515 0 ELECTRICAL PARTS LIST NOTE: When indicating parts by reference • Due to standardization, replacements in the • Items marked “*” are not stocked since they number, please include the board. parts list may be different from the parts speci- are seldom required for routine service.
Page 32
XR-C2600 3 7 63 1515 0 L 13942296513 u163 Sony Corporation 9-870-063-11 2000B0524-1 Mobile Electronics Division Company Printed in Japan C 2000. 2 Published by General Engineering Dept. http://www.xiaoyu163.com...