Installing The Fuel Tank - KTM 250 SX-F EU Owner's Manual

SERVICE WORK ON THE CHASSIS

Installing the fuel tank

x
10.33
Danger
Fire hazard Fuel is highly flammable.
–
Never refuel the vehicle near open flames or burning cigarettes, and always switch off the engine first. Be careful that no
fuel is spilt, especially on hot vehicle components. Clean up spilt fuel immediately.
–
Fuel in the fuel tank expands when warm and can escape if the tank is overfilled. See the notes on refueling.
Warning
Danger of poisoning Fuel is poisonous and a health hazard.
–
Avoid contact of the fuel with skin, eyes and clothing. Do not inhale fuel vapors. If fuel gets into your eyes, rinse imme-
diately with water and contact a doctor. Wash affected skin areas immediately with soap and water. If fuel is swallowed,
contact a doctor immediately. Change clothing that has come into contact with fuel.
–
Disconnect the plug-in connection of the fuel line.
–
Mount wash cap set
Wash cap set (81212016000)
–
Remove the tube from the fuel tank breather.
100949-10
–
Remove screws
B00315-10
–
Remove screw
B00316-10
–
Pull both spoilers off of the sides of the radiator bracket and lift off the fuel tank.
B00319-10
–
Check the throttle cable routing. (
.

with the collar bushing.

with the rubber bushing.

p. 48)
43