Page 3
Drawing : - TPC252 Issue : - 6 Date : - 10/12/13 Page 3 of 16...
Page 4
: - 10/12/13 UNPACKING Carefully remove the CD425 dehumidifier unit from its packing and visually check for signs of transit damage. If there is evidence of damage DO NOT attempt to operate the unit, call your supplier for advice. Do not discard the packing, as it will be useful when transporting the dehumidifier unit in the future.
: - 10/12/13 OPERATION The CD425 is a self contained low temperature dehumidifier. All electrical contactors, overloads, etc are housed in an electrical box built inside the unit. The unit is equipped with a defrost valve which energized automatically to clear any ice formation on the evaporator coils.
Page 7
SYSTEM INSALLATION POSITIONING Position the CD425 in the area leaving enough room either end of the unit to allow for easy servicing. Using a spirit level ensure the level in both direction. Failure to do so may result in the drain tray overflowing and flooding of the chamber.
Drawing : - TPC252 Issue : - 6 Date : - 10/12/13 ROUTINE MAINTENANCE WARNING: ENSURE THAT THE POWER CORD TO THE MACHINE HAS BEEN DISCONNECTED BEFORE CARRYING OUT ROUTINE MAINTENACE ON ITEMS 1, 2, 3, 4, AND 5. To ensure continued full efficiency of the dehumidifier, maintenance procedures should be performed as follows: 1.
Page 9
Drawing : - TPC252 Issue : - 6 Date : - 10/12/13 REPAIRS Should an electrical component fail, consult the Factory Service Center to obtain the proper replacement part. If refrigerant gas is lost from the machine, it will be necessary to use a refrigeration technician to correct the fault.
Drawing : - TPC252 Issue : - 6 Date : - 10/12/13 TROUBLESHOOTING YMPTOM AUSE EMEDY 1. Check the power from the Unit inoperative 1. No power to unit power supply panel 1. Tighten fan 1. Loose fan on shaft 2.
Drawing : - TPC252 Issue : - 6 Date : - 10/12/13 LIMITED WARRANTY Our products carry a one-year unconditional warranty against any defects in workmanship or material. This warranty will cover all parts and labor required to repair your Ebac product. This warranty is invalid if the unit has been abused, damaged, whether intentional or accidental, or if any modifications have been made to the unit.
Page 14
Drawing : - TPC252 Issue : - 6 Date : - 10/12/13 Page 14 of 16...
Page 15
Drawing : - TPC252 Issue : - 6 Date : - 10/12/13 Page 15 of 16...