Battery - Gasoline Vehicles - Club Car Golf Car Series Owner's Manual

Battery – Gasoline Vehicles
BATTERY – GASOLINE VEHICLES
See General Warnings on page 12.
DANGER
• Battery – Explosive gases! Do not smoke. Keep sparks and flames away from the vehicle and service
area. Ventilate when charging or operating vehicle in an enclosed area. Wear a full face shield and
rubber gloves when working on or near batteries.
• Tools, wires, and metal objects can cause sparks when shorted across a battery.
• Follow all instructions carefully when working with batteries.
• Charge battery in a well-ventilated area only.
• Battery – Poison! Contains acid! Causes severe burns. Avoid contact with skin, eyes, or clothing.
Antidotes:
– External: Flush with water. Call a physician immediately.
– Internal: Drink large quantities of milk or water followed with milk of magnesia or vegetable
oil. Call a physician immediately.
– Eyes: Flush with water for 15 minutes. Call a physician immediately.
WARNING
• Do not jump start a dead battery using another battery and jumper cables.
The battery in the Club Car gasoline vehicle is a 12-volt, low maintenance battery that requires infrequent watering
(Figure 30).
Any corrosion around the positive (+) or negative (–) terminals should be washed off with a solution of baking soda
and water (1 cup (237 mL) per 1 gallon (3.8 L) of water). Rinse solution off the battery. Do not allow this solution to
enter battery. Be sure terminals are tight. Let the terminals dry and then spray them with Battery Terminal Protector
Spray (CC P/N 1014305). See Connecting the Battery – Gasoline Vehicles on page 14. See preceding and
following WARNINGS.
WARNING
• If battery wire terminals are damaged or corroded, replace or clean them as necessary. Failure to
do so may cause them to overheat during operation and could result in fire, property damage, or
personal injury.
Be sure battery clamp is properly tightened. Tighten to 144 in-lb (16 N·m). A loose battery clamp may allow the
battery to become damaged from vibration or jarring.
If battery appears weak, have it charged by a trained technician. The battery should never be left discharged any
longer than absolutely necessary (do not leave discharged overnight).
Page 52 Precedent Gold Standard Remanufactured Vehicle Owner's Manual