Product Specifi C And Important Safety Information; Appliance Certifi Cation; Btu Specifi Cations; High Altitude Installations - Outdoor Lifestyles CARODG36I-B Installation Manual

1 1
Product Specifi c and Important Safety Information
A. Appliance Certifi cation
MODELS: CARODG36I-B, CARODG42I-B
LABORATORY: Underwriters Laboratories, Inc. (UL)
TYPE: Outdoor Decorative Gas Appliances
STANDARD: ANSI Z21.97-2014, CSA 2.41-2014
This product is listed to ANSI standards for "Outdoor Dec-
orative Gas Appliances" and "Gas Fired Appliances for
Use at High Altitudes."
NOTICE: This installation must conform with local codes.
In the absence of local codes you must comply with the
National Fuel Gas Code, ANSI Z223.1-latest edition in
the U.S.A. and the CAN/CGA B149 Installation Codes in
Canada.
When an appliance is for connection to a fi xed piping sys-
tem, the installation must conform with local codes, or in
the absence of local codes with the National Fuel Gas
Code, ANSI Z223.1/NFPA 54, or International Fuel Gas
Code.
B. BTU Specifi cations
Models
CARODG36I-B (NG)
CARODG36I-B (LP)
CARODG42I-B (NG)
CARODG42I-B (LP)
Outdoor Lifestyles by Hearth & Home Technologies Inc. • Carolina-B Installation Manual • 4066-500 Rev. B • 5/14
4
Min/Max Input Orifi ce Size
BTUH (DMS)
36,000/55,000 #27 / .144
29,000/50,000 #46 / .081
33,000/65,000 #24 / .152
37,000/62,000 #43 / .089
C. High Altitude Installations
NOTICE: If the heating value of the gas has been reduced,
these rules do not apply. Check with your local gas utility
or authorities having jurisdiction.
When installing above 2000 feet elevation:
• In the USA: Reduce input rate 4% for each 1000 feet
above 2000 feet.
• In CANADA: Input ratings are certifi ed without a
reduction of input rate for elevations up to 4500 feet
(1370 m)above sea level. Please consult provincial and/
or local authorities having jurisdiction for installations at
elevations above 4500 feet (1370 m).
Check with your local gas utility to determine proper
orifi ce size.
D. Non-Combustible Materials Specifi cation
Material which will not ignite and burn. Such materials are
those consisting entirely of steel, iron, brick, tile, concrete,
slate, glass or plasters, or any combination thereof.
Materials that are reported as passing ASTM E 136,
Standard Test Method for Behavior of Materials in
a Vertical Tube Furnace at 750 ºC shall be considered
non-combustible materials.
E. Combustible Materials Specifi cation
Materials made of or surfaced with wood, compressed pa-
per, plant fi bers, plastics, or other material that can ignite
and burn, whether fl ame proofed or not, or plastered or
unplastered shall be considered combustible materials.
F. Electrical Codes
NOTICE: This appliance must be electrically wired
and grounded in accordance with local codes or, in the
absence of local codes, with National Electric Code
ANSI/NFPA 70-latest edition or the Canadian Electric
Code CSA C22.1.
• A 110-120 VAC circuit for this product must be pro-
tected with ground-fault circuit-interrupter protection,
in compliance with the applicable electrical codes,
when it is installed in locations such as in bathrooms
or near sinks.
G. Fuel
This appliance must not be used to burn solid fuel.