Advertisement

INSTALLER: Leave this manual with party responsible for use and operation.
OWNER: Retain this manual for future reference.
NOTICE: DO NOT discard this manual!
Models:
WARNING!
Risk of Fire!
Do not install glass doors on this fireplace.
Glass doors could cause overheating of
adjacent structures.
DANGER
Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner's Manual • 4067-981 Rev. B • 8/17
Owner's Manual

Care and Operation

DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. If odor continues, keep away from the
appliance and immediately call your gas
supplier or fire department.
WARNING: For Outdoor Use Only.
WARNING
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
An LP-cylinder not connected for use shall not
be stored in the vicinity of this or any other
appliance.
WARNING:
Improper installation, adjustment,
alteration, service or maintenance can cause injury or property
damage. Read the installation, operating and maintenance
instructions thoroughly before installing or servicing this
equipment.
CARBON MONOXIDE HAZARD
This appliance can produce carbon monoxide
which has no odor.
Using it in an enclosed space can kill you.
Never use this appliance in an enclosed space
such as a camper, tent or home.
1

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the CARODG36I-C and is the answer not in the manual?

Questions and answers

Summary of Contents for Outdoor Lifestyles CARODG36I-C

  • Page 1: Care And Operation

    Using it in an enclosed space can kill you. Never use this appliance in an enclosed space such as a camper, tent or home. Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 2: Welcome

    Maximum Pressure (Pression) ........... X.X in. w.c. (Po. Col. D’eau) Maximum Input BTUH: ............XX,XXX Serial: Orifice Size: ................ #XX/XXX (Série): Model Number Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 3: Table Of Contents

    C. Contact Information ......24  = Contains updated information. Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 4: Limited Warranty

    Outdoor Lifestyles Warranty - 2108-975B - 2/15/13 - page 1 Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 5 The duration of any implied warranty is limited to the duration of the warranty period specified herein. Outdoor Lifestyles Warranty - 2108-975B - 2/15/13 - page 2 Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 6: Product Specific Information

    CARODG36I-C (NG) 55,000 #27 / .144 CARODG36I-C (LP) 50,000 #46 / .081 CARODG42I-C (NG) 65,000 #24 / .152 CARODG42I-C (LP) 62,000 #43 / .089 Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 7: Appliance Safety

    Contact your dealer for more information, or visit: www. are contacting the top of the firebox. Call a qualified service hpba.org/safety-information. technician to service the appliance Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 8: General Operating Parts

    • Conversions must be made by a qualified service technician using Hearth & Home Technologies specified and approved parts. Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 9: Lighting Instructions (Ipi)

    See installation and operating instructions accompanying appliance. For additional information on operating your Hearth & Home Technologies fireplace, please refer to www.fireplaces.com. Final inspection by Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 10: Appliance Break-In

    H. Operation During A Power Outage (IPI) This model requires electrical power for operation. It will not be functional during a power outage. Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 11: Maintenance And Service

    • Vacuum and dust surfaces. NOTICE: Soot may accumulate on the logs, pilot assembly, and the area above the firebox opening. Periodic cleaning may be required. Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 12: Maintenance Tasks - Qualified Service Technician

    Figure 4.2. Surface plane of firebox is comprised and should be replaced. Figure 4.1 IPI Pilot Flame Patterns NOTE: Appearance of rock jig, pilot shield and media tray may vary between appliance models. Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 13 Figure 4.7. Notch against grate Figure 4.4 Place Left Front Log Figure 4.7 Place Top Right Log Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 14 Place the top log on the indentations of the left front log and the back log as shown in Figure 4.10 for Carolina-36. Figure 4.10 Place Top Log in Center- Carolina 36 Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 15: Frequently Asked Questions And Troubleshooting

    Installer’s Manual for this the touch. appliance. Contact your dealer for additional information regarding operation and troubleshooting. Visit www.hearthnhome.com to locate a dealer. Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 16: Troubleshooting

    .095 in. (2.41 mm) to .135 in. (3.43 mm). C. Module is not grounded. Verify module is securely grounded to metal chassis of appliance. Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 17 ON position. If there is no spark at “I” terminal module must be replaced. If there is a spark at “I” terminal, module is fine. Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 18: Reference Materials

    Hearth & Home Technologies-approved optional acces- sories with this appliance. Using non-listed accessories could result in a safety hazard and will void the warranty. Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 19: Service Parts

    Carolina 36” Outdoor Beginning Manufacturing Date: Aug 2017 Gas Fireplace Ending Manufacturing Date: Active Log Set Assembly Part number list on following page. 08/17 Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 20 Pilot Ori ce NG 593-528 Pilot Ori ce LP 593-527 Regulator NG NGK-DXF Regulator LP LPK-DXF Additional service part numbers appear on following page. Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 21 Carolina 42” Outdoor Beginning Manufacturing Date: Aug 2017 Gas Fireplace Ending Manufacturing Date: Active Log Set Assembly Part number list on following page. Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 22 Pilot Ori ce NG 593-528 Pilot Ori ce LP 593-527 Regulator NG NGK-DXF Regulator LP LPK-DXF Additional service part numbers appear on following page. Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 23 Valve Bracket 4066-299 18.9 Flex Ball Valve Assembly 2078-022 18.10 90 Degree Elbow 4021-045 Valve NG 593-500 18.11 Valve LP 593-501 Transformer, 3V 593-593A Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...
  • Page 24: Contact Information

    5941237, 6006743, 6019099, 6053165, 6145502, 6374822, 6484712, 6601579, 6769426, 6863064, 7077122, 7098269, 7258116, 7470729, 8147240 or other U.S. and foreign patents pending. 2000-945C Printed in U.S.A. - Copyright 2017 Outdoor Lifestyles by Hearth & Home Technologies • Carolina-C Owner’s Manual • 4067-981 Rev. B • 8/17...

This manual is also suitable for:

Carodg42i-c

Table of Contents