Table of Contents
Advertisement
~
~~
~
~~~~
~~~
SERVICE
TROUBLESHOOTING
Listed below are some problems you may have, and their solutions.
PROBLEM
or misty
Pattern too thin
Pattern too
heavy
Runs or sags in
paint
Splatter
SOLUTION
Adjust flow control to proper set-
ting, see page 4. Excessive shaking
may cause air bubbles; let paint
settle.
Adjust flow control to proper set-
ting, see page
4.
don't over thin paint. Start moving
Move faster, see box 5 , page 3,
before triggering.
Wipe off gate opening, hold
valve to proper setting. Cup over-
painter level, adjust flow control
filled,
see
box 1 , page 3.
REPLACEMENT PARTS
To order replacement parts, use the special order form
307-377 included. Copies are available, without charge,
from GRACO, if extras are needed.
NOTE
Do not modify the PAINTMASTER in anyway,
or use non-Graco replacement parts.
TECHNICAL
DATA
Electrical : 120 VAC,
60
Hz,
2.5 Amp rating
Weight : 3 Ib 4
02.
(1.5 kg) (less paint)
PROBLEM
Motor speeds
U P
Paint stops
when using ceil-
ing adapter
Motor over-
down
heats, slows
Motor runs er-
ratically or
stops
SOLUTION
Refill cup, see box 1, page 3.
Check adapter position
it
should
point to rear of cup. Don't push
adapter too far onto tube.
Check for plugged vent slots.
Clean
Brushes may need replacing. See
note below.
HANDLE and MOTOR REPAIR
HANDLE and MOTOR REPAIR
Any service to this assembly must be done by an
authorized Graco Service Center. Return the motor and
handle assembly to Graco.
ACCESSORY
(Must be purchased separately).
25
ft, 3-wire, 18 gauge,
10 Amp,
UL Listed
GROUNDED EXTENSION CORD 104-774
The
PAINTMASTER
Warranty
A One-Year Limited Warranty
Graco Inc. promises to repair or replace, at no cost for parts or labor, any PAINTMASTER painter
date of purchase and extends to We original purchaser only.
which is defective
in
materials or workmanship. This promise applies for one year after the original
If you believe that your PAINTMASTER is defective:
1. Mail the PAINTMASTER and vour oroof of Durchase to the address
2. Graco will inspect your PAINTMASTER, advise you whether the pro-
duct is defective and. if so, will repair or replace your PAINTMASTER
at no charge to you.
This warranty does
not
cover damage or wear caussd by misuse, abrasion, corrosion, negligence, acci-
dent, or tampering.
GRACOS RESPONSIBILITY IS LlMiTED TO THE REPAIR OR REPLACEMENT OF
ANY PAINT-
MASTER WHICH
I S
DEFECTIVE IN MATERIAL
OR
WORKMANSHIP. IN NO EVENT AND UNDER NO
CIRCUMSTANCES SHALL GRACO HAVE LIABILITY
FOR CONSEOUENTIAL OR INCIDENTAL
TING. CLEANiNG UP A PAINT SPILL AND LOST TIME.) IT IS EXPRESSLY UNDERSTOOD THAT
DAMAGES. (CONSEQUENTIAL AND INCIDENTAL DAMAGES INCLUDE SUCH THINGS AS REPAIN-
THE TERMS OF THIS WARRANTY CONSTITUTE THE PURCHASER'S SOLE REMEDY. ALL IMPLIED
GRACO'S LIABILITY CAN NEVER EXCEED THE PURCHASE PRICE OF THIS PRODUCT, AND THAT
WARRANTIES OF MERCHANTABILITY AND FITNESS FOR USE ARE LiMiTED TO THE DURATION
OF THE EXPRESS WARRANTY.
not apply to you. Some states do not permit limitations
of
consequential or incidental damages, so the
Some states do not allow a limitation
on
how
long
implied warranties last, so the above limitation may
above disclaimer and limitation mav not aoolv to
YOU.
This warrantv aives
vou
soecific lenal riohts. and
you may also have other rights w h k h v a i f i o m state to state.
, I
.
.
I
"
SERVICE CENTERS
GRACO INC.
6820-D
SHINGLE CREEK PARKWAY
CONSUMER PRODUCTS DIVISION
BROOKLYN CENTER,
MN
55430
GRACO
INC.
(CALIFORNIA CUSTOMERS ONLY/
CONSUMER PRODUCTS DIVISION
~
~~
~
3165
SOUTH GARFIELD
LOS
ANGELES COMMERCE, C A
9o040
~~~
PRINTED
IN
U.S.A.
307-376
3-80
Advertisement
Table of Contents
