Hitachi 57F59A Service Manual page 37

2.10 LENS FOCUS ADJUSTMENT
Adjustment preparation
(1) The orientation of PTV set is arbitrary, west,
east, north and south.
(2) Centering DY inclination should have been
adjusted.
(3) Static focus adjustment should have been
coarse adjusted.
(4) Drive VR location adjustment should have been
completed. (Red : 12 O'clock, Green : 1~2
O'clock).
(5) Receive the cross-hatch pattern signal.
(6) Refer to setup below.
CONTRAST : HALF of full scale.
BRIGHTNESS : minimum
Adjustment procedure
(1) Loosen the fixing screw or wing nut on the lens
cylinder so that the lens cylinder can be turned.
(Be careful not to loosen too much).
completing steps (4), (5), (6) below, tighten the
fixing screws or wing nuts for each lens with a
torque of 1.18N.m (12Kgf cm) ~ 1.67N.m (17Kgf
cm).
(Be careful the lens cylinder does not turn after
having tightened the screw or wing nuts. If it is
tightened too much, lens may tilt or screw may
break.)
Lens Assy
(NOTE 1)
Fixing Screw
TYPE 1
BACK TO ADJUSTMENTS
After
Lens Assy
(NOTE 2)
Fixing Wing Nut
TYPE 2
36
(2) Apply covers to each color of R, G and B lenses.
And project a single color on the screen and
adjust in sequence. (The adjustment order of G,
R and B is only an example.)
(3) If the lens adjustment knob is turned clockwise
viewed from the front, the color Aberration
change as follows.
Cross-Hatch
Change of Color Aberration
Short focus
RED LENS Orange
GREEN LENS Blue
BLUE LENS Purple
(4) In case of G lens. Set to the point where the
chromatic aberration switches from blue to red.
RED LENS
If the chromatic aberration appearing all over
GREEN LENS
the screen is not the same, observe the vertical
bright line and adjust lens focus as specified in BLUE LENS
table below. When the red chromatic aberration
appearing at both sides of the bright line is not
equal, observe the side with larger chromatic
aberration when adjusting.
L1 L2
I
DP65
Color
Aberration
Long focus
Scarlet
Red
Green
Change of Color Aberration
Short focus Long focus
Orange Scarlet
Blue Red
Purple Green
O