Warranty - Pro-Fab Industries Cozeburn Installation And Operation Instructions Manual

10 Year Limited Warranty
Warranty service may only be performed by Pro-Fab Industries
or a Pro-Fab Authorized Cozeburn Furnace Dealer or a Pro-Fab
Authorized Cozeburn Furnace Service Centre.
PRO-FAB INDUSTRIES INC. WARRANTY
Pro-Fab Industries Inc. (hereinafter called "Pro-Fab") warrants
to the original owner of the Cozeburn Furnace (hereinafter
called the "Cozeburn") the following:
A two (2) year warranty on the workmanship of the furnace and
workmanship on all parts manufactured by Pro-Fab, from the
consumer date of purchase, and excluding normal wear items
such as (but not limited to) the door gasket, fire brick (if appli-
cable), insulation, exterior finish and chimney.
A one (1) year warranty for any labour required for any repair or
replacement of the furnace or parts from the consumer date of
purchase based on Pro-Fab's predetermined labour rates and al-
lowable hours.
A limited pro-rated warranty coverage (which includes the one (1)
year labour coverage at Pro-Fab rates and hours as stated above)
for a defective firebox and water jacket only, based on the follow-
ing pro-rated scale from the consumer date of purchase:
• Years one (1) and two (2) – one hundred percent
(100%) coverage;
• Years three (3), four (4) and five (5) – sixty percent (60%)
coverage;
• Years six (6) and seven (7) – thirty percent (30%)
coverage;
• Years eight (8) and nine (9) – fifteen percent (15%)
coverage;
Pro-Fab will not be responsible or liable for any of the following: a)
If warranty work requires removal or replacement of all or a part of
the furnace, Pro-Fab is not responsible for the cost of plumbing,
freight, permits, removal or disposal of damaged furnace or parts,
replacement of water or additives, labour after the one (1) year war-
ranty coverage expires, or any cost other than the warrantied re-
placement part itself or the furnace; b) The care, maintenance and
safe operation of the Cozeburn Furnace, which is the responsibility
of the owner of the furnace; c) Any accidents, injury, damage or
loss incurred due to a heating system failure; d) Any accidents,
injury, damage or loss incurred due to faulty installation, operation
or maintenance; e) Any cost incurred for replacing or repairing of
parts not manufactured by Pro-Fab which carry their own manu-
facturer's warranty (except for the one (1) year labour coverage
at Pro-Fab rates and hours as stated above); f) Any out-of-pocket
expenses, alternative accommodations or loss of revenue due to
defective parts or furnace; g) Performance problems caused by
improper sizing of the furnace, vent connection, or air openings;
There are no other warranties, expressed or implied, by Pro-Fab or
its Authorized Cozeburn Furnace Dealers or Authorized Cozeburn
Furnace Service Centres regarding the Cozeburn Furnace except
the warranty expressed herein. ANY IMPLIED WARRANTIES, IN-
CLUDING MERCHANTABILITY, OR FITNESS FOR A PARTICULAR
PURPOSE, SHALL NOT EXTEND BEYOND THE APPLICABLE
WARRANTY PERIODS SPECIFIED ABOVE. PRO-FAB'S SOLE
LIABILITY, WITH RESPECT TO ANY DEFECT, SHALL BE AS SET
FORTH IN THIS LIMITED WARRANTY, AND ANY CLAIMS FOR IN-
CIDENTAL OR CONSEQUENTIAL DAMAGES ARE EXCLUDED.
Issue Date: June 2012 Part No: 815378R04
• Year ten (10) – ten percent (10%) coverage.
Absolutely no warranty is provided after ten (10) years from
the consumer date of purchase.
Note: All parts NOT manufactured by Pro-Fab carry their own
manufacturer's warranty. The owner is responsible for all costs
necessary to replace those parts unless covered by the appli-
cable manufacturer (except for the one (1) year labour cover-
age at Pro-Fab rates and hours as stated above).
The above warranties are based on the following factors:
Pro-Fab reserves the right to repair or replace at its discretion
any defective part or furnace, in whole or in part.
Use of Pro-Fab approved water treatment. IMPORTANT: Pro-
Fab approved water treatment is available from your local
dealer or service centre and must be used and validated for
warranty coverage. The pH balance must remain between 8.8
and 11.0, the nitrite level must remain between 730 and 1460
ppm as NaNO2, and conductivity must be less than or equal to
4000 mmhos. A copy of the invoice itemizing the purchase of
approved water treatment will be required as proof of mainte-
nance in the event of a warranty claim. All laboratory reports
must be kept as proof of maintenance (as indicated in the In-
stallation and Operation Instruction Manual).
All instructions in the Cozeburn Installation and Operation In-
struction Manual must be followed.
The Warranty Registration and a copy of the original bill (in-
voice) must be forwarded to Pro-Fab within thirty (30) days of
the consumer date of purchase to validate the warranty.
h) Damages, malfunctions or failures resulting from the use of any
attachment not authorized by Pro-Fab; i) Units installed outside the
continental United States, Alaska, or the provinces and territories
of Canada without prior approval from Pro-Fab; j) Units with their
safety certification labels removed; or k) Damages, malfunctions
or failures caused by force majeure, abuse, accident, fire, or acts
of God.
Any available warranty will be void if: a) Maintenance procedures
are not followed (as indicated in the Installation and Operation
Instruction Manual); b) Water treatment and proper additives are
not used as specified in the Installation and Operation Instruction
Manual ; c) The Cozeburn Furnace has been altered in any way; d)
Any material other than Pro-Fab approved fuel has been used; e)
Any instruction given in the Installation and Operation Instruction
Manual which has not been followed including during installation
or regular maintenance; or f) Any claim made under the warranty
for a person other than the original owner.
No person is authorized to bind Pro-Fab to any other warranty
whatsoever.
Pro-Fab reserves the right at any time to make changes or improve-
ments to the design, materials, or specifications of the Cozeburn
line of furnaces or parts without thereby becoming liable to make
similar changes in the furnaces or any of its parts previously manu-
factured.
Manufactured by:
Pro-Fab Industries Inc.
Box 112 Arborg, MB R0C 0A0
Printed in Canada JW0612