Related Manuals for Aaeon AOP-8150
Summary of Contents for Aaeon AOP-8150
- Page 1 F a n l e s s O p e r a t o r P a n e l A O P - 8 1 5 0 AOP-8150 ® ® Intel ULV Celeron 650MHz Processor Fanless Operator Panel with 15” TFT LCD AOP-8150 Series User Manual Rev.A 2 Ed - 1 -...
-
Page 2: Copyright Notice
The material in this document is for product information only and is subject to change without notice. While reasonable efforts have been made in the preparation of this document to assure its accuracy, AAEON, assumes no liabilities resulting from errors or omissions in this document, or from the use of the information contained herein. -
Page 3: Acknowledgments
UMC is a trademark of United Microelectronics Corporation. SMI is a trademark of Silicon Motion, Inc. Creative is a trademark of Creative Technology LTD. All other product names or trademarks are properties of their respective owners. AOP-8150 Series User Manual Rev.A 2 Ed - 3 -... -
Page 4: Packing List
Power cord (optional) • Transfer board for CD-ROM (optional) • CD-ROM for manual (in PDF format) and drivers If any of these items are missing or damaged, contact your distributor or sales representative immediately. AOP-8150 Series User Manual V1.0 - 4 -... - Page 5 3. Maintenance: to properly maintain and clean the surfaces, use only approved products or clean with a dry applicator 4. Do not remove CompactFlash storage card while reading from or writing into the storage card. AOP-8150 Series User Manual Rev.A 2 Ed - 5 -...
-
Page 6: Safety & Warranty
12. Never pour any liquid into an opening. This may cause fire or electrical shock. 13. Never open the equipment. For safety reasons, the equipment should be opened only by qualified service personnel. AOP-8150 Series User Manual V1.0 - 6 -... - Page 7 MANUFACTURER, DISCARD USED BATTERIES ACCORDING TO THE MANUFACTURER'S INSTRUCTIONS. DISCLAIMER: This set of instructions is given according to IEC 704-1. AAEON disclaims all responsibility for the accuracy of any statements contained herein. AOP-8150 Series User Manual Rev.A 2 Ed - 7 -...
-
Page 8: Table Of Contents
Digital I/O 8 bit Connector (CN9) ........35 COM2 RS-232/422/485 Selection (JP4 & JP5) ..36 Chapter 3 BIOS Installation ..........37 System Test and Initialization ........38 Award BIOS Setup .............39 Chapter 4 Driver Installation ..........42 Installation ..............44 FAQ ................46 AOP-8150 Series User Manual V1.0 - 8 -... -
Page 9: Chapter 1 General Information
F a n l e s s O p e r a t o r P a n e l A O P - 8 1 5 0 Chapter General Information AOP-8150 Series User Manual Rev.A 2 Ed - 9 -... -
Page 10: Introduction
A O P - 8 1 5 0 Introduction The AOP-8150 panel PC is a Ultra Low Voltage Low power Celeron processor computer that is designed to serve as a human machine interface (HMI) and as a multimedia computer. It is a PC-based system with 15"... -
Page 11: Features
Slim and Fanless solution: All-in-one SBC with Intel ® Celeron 650MHz CPU onboard • ® ® Windows CE.NET 4.2 and Windows XP Embedded support (optional) • 10/100Base-T or Giga Ethernet (Optional) AOP-8150 Series User Manual Rev.A 2 Ed - 11 -... -
Page 12: Specification
1 x parallel port 1 x VGA port 1 x PS/2 keyboard, 1 x PS/2 mouse Audio Mic In, Line in, Line out, S/P DIF Out (for 5.1 channel audio) Ethernet One 10/100Base-T RJ-45 connector AOP-8150 Series User Manual V1.0 - 12 -... - Page 13 Display Type 15” color TFT LCD • Max. Resolution 1024 x 768 • Max. Colors 262,144 • Dot Size 0.297mm x 0.297mm • Luminance 250 cd/m2 • Viewing Angle (H) 145 AOP-8150 Series User Manual Rev.A 2 Ed - 13 -...
- Page 14 Panelmount, VESA 100mm, Desk Stand (Optional) • Dimension 16” (W) x 12.2” (H) x 2.6” (D) (407mm x 310.5mm x 65mm) • Cutout Size 394 x 297.5 mm • Gross Weight 6 Kg AOP-8150 Series User Manual V1.0 - 14 -...
- Page 15 F a n l e s s O p e r a t o r P a n e l A O P - 8 1 5 0 Note: All AAEON's LCD products are manufactured with High precision technology. However, in all LCD panels there maybe a small number of defective pixels that do not change color.
- Page 16 Rear Side Front Side CRT D-Sub Parallel Port 10/100 Base-T Ethernet COM 5 COM 6 Connector 4 USB 2.0 ports COM 1 COM 2 COM 3 Digital I/O Line out/Line in/Mac in AOP-8150 Series User Manual V1.0 - 16 -...
-
Page 17: Dimension
F a n l e s s O p e r a t o r P a n e l A O P - 8 1 5 0 Dimension Cutout Size: 394 x 297.5 mm 391.0 65.0 407.0 391.0 With PCI extension kit 93.6 407.0 AOP-8150 Series User Manual Rev.A 2 Ed - 17 -... -
Page 18: Chapter 2 Hardware Installation
F a n l e s s O p e r a t o r P a n e l A O P - 8 1 5 0 Chapter Hardware Installation AOP-8150 Series User Manual V1.0 - 18 -... -
Page 19: Cd-Rom Installation
F a n l e s s O p e r a t o r P a n e l A O P - 8 1 5 0 CD-ROM Installation 1. Disassemble the plastic cover of the monitor. AOP-8150 Series User Manual Rev.A 2 Ed - 19 -... - Page 20 F a n l e s s O p e r a t o r P a n e l A O P - 8 1 5 0 2. Lock the transfer board (the board is at accessory box) Lock the CD-ROM with the bracket AOP-8150 Series User Manual V1.0 - 20 -...
- Page 21 F a n l e s s O p e r a t o r P a n e l A O P - 8 1 5 0 3. Disassemble the CD-ROM cover 4. Insert IDE cable and Power cable into CD-ROM module AOP-8150 Series User Manual Rev.A 2 Ed - 21 -...
- Page 22 F a n l e s s O p e r a t o r P a n e l A O P - 8 1 5 0 5. Fix the CD-ROM module in the AOP-8150 6. Lock the plastic cover of the monitor and complete the installation AOP-8150 Series User Manual V1.0 - 22 -...
-
Page 23: 2.5" Hard Disk Drive Installation
We’ll show you how to install the Hard Disk Drive into the Panel PC. When you prepare the following items at hand, you can start to your installation. 1. Disassemble HDD cover 2. Disassemble HDD module AOP-8150 Series User Manual Rev.A 2 Ed - 23 -... - Page 24 F a n l e s s O p e r a t o r P a n e l A O P - 8 1 5 0 3. Put off the HDD upper cover 4. Insert IDE cable into HDD AOP-8150 Series User Manual V1.0 - 24 -...
- Page 25 F a n l e s s O p e r a t o r P a n e l A O P - 8 1 5 0 A O P - 8 1 5 0 AOP-8150 Series User Manual Rev.A 2 AOP-8150 Series User Manual Rev.A 2 Ed - 25 -...
- Page 26 F a n l e s s O p e r a t o r P a n e l A O P - 8 1 5 0 5. Put HDD into the base 6. Fix the HDD cover with screws AOP-8150 Series User Manual V1.0 - 26 -...
- Page 27 F a n l e s s O p e r a t o r P a n e l A O P - 8 1 5 0 7. Fix the cover with screws AOP-8150 Series User Manual Rev.A 2 Ed - 27 -...
-
Page 28: Pci Extension Kit Installation
A O P - 8 1 5 0 PCI extension kit Installation PCI extension kit will be attached along with the package. Please see the following steps for details. Step 1: Get the rack ready AOP-8150 Series User Manual V1.0 - 28 -... - Page 29 A O P - 8 1 5 0 Step 2: Unlock the bar indicated. Step 3: Plug Riser card into the socket beneath the bar, and plug the rack on the back of AOP-8150. AOP-8150 Series User Manual Rev.A 2 Ed - 29 -...
- Page 30 F a n l e s s O p e r a t o r P a n e l A O P - 8 1 5 0 Step 4: Fix the rack with the screws on the corners. Step 5: Plug your PCI card into the white slot indicated. AOP-8150 Series User Manual V1.0 - 30 -...
- Page 31 F a n l e s s O p e r a t o r P a n e l A O P - 8 1 5 0 A O P - 8 1 5 0 AOP-8150 Series User Manual Rev.A 2 AOP-8150 Series User Manual Rev.A 2 Ed - 31 -...
- Page 32 F a n l e s s O p e r a t o r P a n e l A O P - 8 1 5 0 Step 6: You have finished PCI extension card installation. Step 7: Put the cover over the back of AOP-8150. AOP-8150 Series User Manual V1.0 - 32 -...
-
Page 33: Panelmount Installation
Step 4: You’ve completed the preliminary when the mounting set is tightened. Next, repeat the steps and tighten all mounting set around the monitor until the monitor is firmly mounting on the wall. AOP-8150 Series User Manual Rev.A 2 Ed - 33 -... - Page 34 F a n l e s s O p e r a t o r P a n e l A O P - 8 1 5 0 Complete Illustration AOP-8150 Series User Manual V1.0 - 34 -...
-
Page 35: Digital I/O 8 Bit Connector (Cn9)
8 IN 8 OUT Note: 4 IN/ 4 OUT, 8 IN, 8 OUT are chosen by BIOS. AOP-8150 (D-SUB 15P Male) Signal Signal DIN1 DIN2 DIN3 DIN4 DOUT1 DOUT2 DOUT3 DOUT4 AOP-8150 Series User Manual Rev.A 2 Ed - 35 -... -
Page 36: Com2 Rs-232/422/485 Selection (Jp4 & Jp5)
F a n l e s s O p e r a t o r P a n e l A O P - 8 1 5 0 COM2 RS-232/422/485 Selection (JP4 & JP5) Function 1-2, 4-5, 7-8, 10-11 RS-232 (Default) 2-3, 5-6, 8-9, 11-12 RS-422 2-3, 5-6, 8-9, 11-12 RS-485 AOP-8150 Series User Manual V1.0 - 36 -... -
Page 37: Chapter 3 Bios Installation
F a n l e s s O p e r a t o r P a n e l A O P - 8 1 5 0 Chapter BIOS Installation AOP-8150 Series User Manual Rev.A 2 Ed - 37 -... -
Page 38: System Test And Initialization
The CMOS memory has lost power and the configuration information has been erased. The AOP-8150 CMOS memory has an integral lithium battery backup for data retention. However, you will need to replace the complete unit when it finally runs down. -
Page 39: Award Bios Setup
Standard CMOS Features Use this menu for basic system configuration. (Date, time, IDE, etc.) Advanced BIOS Features Use this menu to set the advanced features available on your system. Advanced Chipset Features AOP-8150 Series User Manual Rev.A 2 Ed - 39 -... - Page 40 Use this menu to load the BIOS default values that are factory settings for optimal performance system operations. While AWARD has designated the custom BIOS to maximize performance, the factory has the right to change these defaults to meet their needs. Set Supervisor/User Password AOP-8150 Series User Manual V1.0 - 40 -...
-
Page 41: Exit Without Saving
Use this menu to set Supervisor/User Passwords. Save and Exit Setup Save CMOS value changes to CMOS and exit setup. Exit Without Saving Abandon all CMOS value changes and exit setup. AOP-8150 Series User Manual Rev.A 2 Ed - 41 -... -
Page 42: Chapter 4 Driver Installation
F a n l e s s O p e r a t o r P a n e l A O P - 8 1 5 0 Chapter Driver Installation AOP-8150 Series User Manual V1.0 - 42 -... - Page 43 F a n l e s s O p e r a t o r P a n e l A O P - 8 1 5 0 The AOP-8150 comes with a CD-ROM that contains all drivers and utilities that meet your needs.
-
Page 44: Installation
F a n l e s s O p e r a t o r P a n e l A O P - 8 1 5 0 Installation Insert the AOP-8150 CD-ROM into the CD-ROM Drive. And install the drivers from Step 1 to Step 5 in order. ®... - Page 45 If you want to equip extra graphic card to support dual view function, the local distributor will give you the technical and exact suggestion and solution. Most graphic cards are not compatible with AOP-8150. Step 5 – Install 6 in 1 Card Reader Driver 1.
-
Page 46: Faq
PSS ID Number: 294820 Article Last Modified on 5/28/2003 The information in this article applies to: ® Microsoft Windows 2000 Server SP1 ® Microsoft Windows 2000 Server SP2 ® Microsoft Windows 2000 Advanced Server SP1 AOP-8150 Series User Manual V1.0 - 46 -... - Page 47 USB CD-ROM device. STATUS Microsoft has confirmed that this is a problem in the Microsoft products that are listed at the beginning of this article. AOP-8150 Series User Manual Rev.A 2 Ed - 47 -...