Approval And Commissioning - Webasto Air Top 2000 ST Installation Instructions Manual

Boat heating systems
9

Approval and Commissioning

Before commissioning, the heater unit must be
approved by an authorised Webasto partner!
• Only put a heater unit into operation when the system has been
completely installed.
• Carefully bleed the fuel supply system. As a result of the low fuel
consumption, the heater must be switched on several times to fill the
fuel line.
• Test run of the heater unit: check all air and fuel
connections for leaks and firm seating.
• If there are any fault messages during operation: conduct
troubleshooting.
• Apply the type label/duplicate type label so that they are easy to read.
Mark the year of initial operation. (Requirement from 2001/56/EC)
Approval and Commissioning
10 Operating Instructions
• Before switching on the unit, check whether the thru hull
for exhaust is clear.
• The unit must be switched off while refuelling.
• Do not operate in closed rooms, e.g. a shipyard - danger
of suffocation.
• Set the adjustable hot air outlets so that they do not blow
hot air directly onto living creatures or temperature-
sensitive objects.
• The area around the heater unit must be kept clear. Do
not store highly flammable or temperature-sensitive objects, such as
plastic containers, oil cans, spray cans, gas cartridges, fire
extinguishers, cleaning cloths, clothing, paper, sails, fenders, etc. on or
next to the heater unit or allow them to come into contact during
rough sailing!
• If fuel escapes: repair the damage immediately! Do not use the heater
unit again until it has been repaired!
• If sea water enters the heater unit: do not start, but instead contact an
authorised Webasto partner.
• Do not prematurely end heater unit run-on (e.g. by actuating the
battery isolation switch), except for emergency shut-down. Emergency
shut-down:
o Remove the fuse or
o Disconnect the heater unit from the battery (actuate the battery
isolation switch).
An emergency shut-down can damage the heater unit!
• Operate the heater unit roughly once a month (also in summer) for
approx. 30 minutes to refresh the fuel in the line.
• Following installation (or acceptance by an authorised Webasto
partner), return the guarantee card to Webasto! Keep the purchase
receipt!
• Inform the insurance company of the installation (adjustment of the
amount insured)!