Related Manuals for Fly Products GOLD 95
Summary of Contents for Fly Products GOLD 95
- Page 1 GOLD 95/115/130 OWNER'S MANUAL Products © Copyright by Via Perù n° 30 63013 GROTTAMMARE (AP) - ITALY tel/fax +39735632486 www.flyproducts.com fly@flyproducts.com...
- Page 2 GOLD 95/115/130 OWNER’S MANUAL VER 10 Index Chapter Description GENERAL INFORMATION UNPACKING AND ASSEMBLING YOUR “GOLD 130-115-95” PREPARING YOUR FIRST FLIGHT FLYING YOUR NEW “GOLD 130-115-95” OPTIONAL ACCESSORIES PACKING YOUR “GOLD 130-115-95”FOR TRAVEL MAINTENANCE TROUBLESHOOTING SPECIFICATION AND PERFORMANCE 10.0 MISCELLANEOUS...
-
Page 3: General Information
This PPG is not covered by product liability insurance Do not start it or fly it unless you are willing to assume all risks inherent in the sport of Powered Paragliding and all responsibility for any... -
Page 4: Unpacking And Assembling
GOLD 95/115/130 OWNER’S MANUAL VER 10 20 UNPACKING AND ASSEMBLING Frame Assembly For an easy and correct assembly proceed in the following order: Step 1 - Place the GOLD’s lower outer frame part on a flat surface and insert the central frame on it... -
Page 5: Harness Mounting
GOLD 95/115/130 OWNER’S MANUAL VER 10 Step 4 : Assembling left hand side outer frame Mount the left hand side outer frame repeating the previous step 2 When done, join upper frames inserts and lock with velcro strap Repeat step 3 on this side... -
Page 6: Harness Adjustment
GOLD 95/115/130 OWNER’S MANUAL VER 10 Next, attach the two bottom harness straps as Fasten these belts securely Do this for the left and right sides Leave these straps at their loosest setting for now, we’ll adjust them later Bottom straps... - Page 7 The ground handling straps as shown above are best adjusted standing on the ground, with the GOLD 95/115/130 on the pilot’s back The purpose of the shoulder straps and shoulder pads is to carry the weight of the GOLD 95/115/130 while on the ground The purpose of the ground handling chest strap is to keep the shoulder pads from sliding off the pilot’s...
-
Page 8: Flight Straps
95/115/130, and every time you make a harness adjustment thereafter A simulator can consist of two ropes tied to a horizontal (and strong) tree limb, two ropes tied to rafters in your garage or basement, etc Once you have made your initial adjustments, strap into the GOLD 95/115/130 and clip the carabiners into the simulator... - Page 9 GOLD 95/115/130 OWNER’S MANUAL VER 10 Upper harness attachment Section is the connection point for Seat set-up paramotore, point instead serves only to connect with trike Flash is inadvisable to use it in paramotore foot lauch off the distance must be done with the 30 cm to 33 cm.
-
Page 10: Prop Mounting
GOLD 95/115/130 OWNER’S MANUAL VER 10 This completes the harness mounting Double check your work to ensure that everything is OK Drive Before installing the propeller, make sure that the reduction (pinion) is the right one for your prop Drive 1:2,4... -
Page 11: Assembly Inspection
The red arrow in picture, indicate the direction of propeller rotation Assembly Inspection It is critical to fully inspect the assembly of the GOLD 95/115/130 to find and remedy any potential problem areas before proceeding The inspection should contain, at a minimum, the following items: ... -
Page 12: Preparing For Your First Flight
30 PREPARING FOR YOUR FIRST FLIGHT Fuel and Oil FLY PRODUCTS recommends the use of a premium unleaded automotive gasoline of 92 octane or higher, and the use of premium synthetic 2-cycle oil Mix fresh gas and oil before each flying session... -
Page 13: Starting The Engine
GOLD 95/115/130 OWNER’S MANUAL VER 10 A – “STOP” button B – “START” button C – Throttle lever D – Cruise control setup E – Velcro strap Multifunction handgrip Since it’s important to know how to stop the engine once it’s started, let’s cover “Stopping the Engine”... - Page 14 GOLD 95/115/130 OWNER’S MANUAL VER 10 If everything is ready as described in the procedure preloads, proceed to place the main lever of breakers security position We’ll cover each of these starting options in turn If the engine is cold it's very important to fill the fuel...
-
Page 15: Carburetor Adjusting
GOLD 95/115/130 OWNER’S MANUAL VER 10 of thermal soaring, and then when he gets low, re-start the engine pressing the START button and climb back up to do it again WARNING! It's very important that immediately after landing, or when the equipment is not in use on... - Page 16 GOLD 95/115/130 OWNER’S MANUAL VER 10 Now carefully open the screw counter clockwise 1turn (turning the screw out in the counter clockwise direction enrich the mix/fuel to air ratio). This is the standard factory setting for L. With the H (meaning High rpm) screw follow the same procedure and turn it clockwise until full closed.
-
Page 17: Engine Break-In
Continue 10 minutes of running, 5 minutes of cooling until 30 minutes of run time is achieved At this point, you can fly the GOLD 95/115/130, however avoid long periods of full power, and vary the throttle setting often... -
Page 18: Optional Accessories
Screwdrivers (both Phillips and Straight) Reserve Parachute A reserve parachute can be fitted to the GOLD 95/115/130, and is a highly recommended safety item Many different mounting locations and methods are possible and acceptable, and the one you choose depends on many things such as which hand you want to deploy with, what type of reserve you have,... -
Page 19: Speed Bar
VER 10 Speed Bar A speed bar can be mounted to the GOLD 95/115/130 harness Optional pulleys can be added to the harness to facilitate the application and routing of the speed-bar These pulleys can be obtained from your GOLD 95/115/130 dealer... -
Page 20: Maintenance
GOLD 95/115/130 OWNER’S MANUAL VER 10 70 MAINTENANCE Periodic maintenance is required in order to keep your GOLD 95/115/130 in top operating condition The following chart provides the suggested maintenance schedule Table 1 INTERVAL INSPECT REPLACE All screws, nuts, bolts, prop cage,... -
Page 21: Prop Care
Cleaning Clean your GOLD 95/115/130 with clean water and a mild soap Dust and dirt can be brushed off, or removed with water and mild soap Grease and oil can be removed with a good water-based degreaser such as “Simple Green”... -
Page 22: Reduction Belt
Minor repairs can be performed on the prop, cage, cage guard, and harness Major repairs should be performed by a trained service technician, or by FLY PRODUCTS Caution! Repairs to the harness or any stress-carrying areas of the GOLD 95/115/130 should only be performed by a certified parachute rigger... -
Page 23: Diagnosing And Starting A Flooded Engine
GOLD 95/115/130 OWNER’S MANUAL VER 10 Store in a clean, dry place 80 TROUBLESHOOTING Diagnosing and starting a flooded engine A flooded engine can be identified by the smell of unburned gasoline coming from the exhaust pipe, or by... -
Page 24: Specification And Performance Summary Chart
GOLD 95/115/130 OWNER’S MANUAL VER 10 Prop out of balance See section 72 Excessive Vibration Loose fasteners Check and tighten engine mounting mounts or attachments bolts, muffler bolts, prop bolts, etc 90 SPECIFICATIONS AND PERFORMANCE Specification and Performance Summary Chart... -
Page 25: Torque Specification Chart
GOLD 95/115/130 OWNER’S MANUAL VER 10 (tandem version) weight Max RPM 7300 RPM Reduction system / Reduction ratio Belt / 2,37:1 2.6:1 Torque Specification Chart ELEMENTS TORQUE (Nm) Cylinder head bolts ( M8 ) Magnet fixing nut ( M12 ) -
Page 26: Electric System
GOLD 95/115/130 OWNER’S MANUAL VER 10 Electric system Following table shows the GOLD ‘s electric connections : Products Page © Copyright by... -
Page 27: Electric Connections Table
GOLD 95/115/130 OWNER’S MANUAL VER 10 Electric connections table - 12V battery – Electric starter – Main switch - Relay – Battery charger – Handgrip plug - Low fuel level float – Stator Products Page © Copyright by... -
Page 28: Obtaining Repair Parts
GOLD 95/115/130 OWNER’S MANUAL VER 10 - Spark coil 100 MISCELLANEOUS Obtaining Repair Parts To obtain repairs parts for your machine, call your FLY PRODUCTS local dealer or FLY PRODUCTS directly G24 - ENGINE SPARE PARTS Products Page © Copyright by... - Page 29 GOLD 95/115/130 OWNER’S MANUAL VER 10 Description CODE Products Page © Copyright by...
-
Page 30: Warranty
GOLD 95/115/130 OWNER’S MANUAL VER 10 G24-01 Battery charger G24-26 Starter crown G24-02 Coil G24-27 Nut and washer G24-03 Long head nut G24-29 Poly-v belt G24-04 Cylinder head G24-30 Prop plate with bolts G24-05 Cylinder head gasket G24-33 Pulley G24-06... - Page 31 GOLD 95/115/130 OWNER’S MANUAL VER 10 FLY PRODUCTS will warrant their product to be free from defects in materials and workmanship for a period Twelve (12) months months from the date of purchase This warranty applies to the product in...
- Page 32 GOLD 95/115/130 OWNER’S MANUAL VER 10 Internet info and upgrade www.flyproducts.com For information, more details and news see our internet site: www.dulv.de For safety information , data and rules you can visit the DULV website: Products © s.r.l. Copyright by Via Perù...