YAMARIN Cross 57 Bow Rider Owner's Manual
  1. Manuals
  2. Brands
  3. YAMARIN Manuals
  4. Boat
  5. Cross 57 Bow Rider
  6. Owner's manual

YAMARIN Cross 57 Bow Rider Owner's Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

Yamarin Cross 57 Bow Rider
Owner's manual

Advertisement

Table of Contents
loading

Related Manuals for YAMARIN Cross 57 Bow Rider

Summary of Contents for YAMARIN Cross 57 Bow Rider

  • Page 1 Yamarin Cross 57 Bow Rider Owner’s manual...
  • Page 2 Any craft, no matter how strong it may be, can be severely damaged if not used properly. Always adjust the speed and direction of the craft to prevailing weather conditions. We wish you enjoyable and relaxing times on board your Yamarin Cross boat! Konekesko Marine PO Box 145 FI-01301 VANTAA, FINLAND Tel.

  • Page 3: Table Of Contents

    Yamarin Cross 57 Bow Rider 3 (51) Table of contents 1 General 1.1 Declaration of conformity 2 Definitions 3 Warranty 4 Before use 4.1 Registration 4.2 Insurance 4.3 Training 5 Characteristics and use of your boat 5.1 General 5.2 Basic data 5.3 Maximum recommended number of passengers...
  • Page 4 Yamarin Cross 57 Bow Rider 4 (51) 6 Servicing and maintenance 6.1 Washing and waxing the boat 6.2 Care instructions for seat cushions 6.3 Care instructions for the canopy (optional accessory) 6.4 Care instructions for the windshield 6.5 Care instructions for the stainless steel components 6.6 Care instructions for the remote control...
  • Page 5 Yamarin Cross 57 Bow Rider 5 (51) BEFORE YOU SET OFF Familiarise yourself with this owner’s manual. Always check at least the following items before leaving: Weather conditions and forecast − − − − Take the wind, waves and visibility into account. Are the design category, size and...

  • Page 6: General

    Yamarin Cross 57 Bow Rider 6 (51) General The owner’s manual will help you familiarise yourself with the properties and features of your new boat and with its care and maintenance. Separate manuals for installed equipment are attached and are referred to in many sections of the owner’s manual. You can supplement this owner’s manual by adding the manuals of devices which are installed...
  • Page 7 Yamarin Cross 57 Bow Rider 7 (51) DECLARATION OF CONFORMITY Recreational Craft Directives 94/25/EC and 2003/44/EC Manufacturer: Fenix Marin Oy Module used: B (EC Type Examination) ----------------------------------------------------------------------------------------------------------------- THIS DECLARATION IS PREPARED BY Marketer: Konekesko Oy Marine Address: Vanha Porvoontie 245...
  • Page 8 Yamarin Cross 57 Bow Rider 8 (51) Boat type: Deck: 01 sailboat 01 decked 02 inflatable 02 partly decked 03 other: motor boat/190> 03 open Hull type: Propulsion: 01 monohull 01 sails 02 multihull 02 petrol engine 03 other: 03 diesel engine...
  • Page 9 Yamarin Cross 57 Bow Rider 9 (51) Inspection standards used Essential safety requirements in the Recreational Craft Directive, by inspection group General requirements Basic information EN ISO 8666:2002 A2.1 Hull Identification Number – CIN ISO 10087:2006 A2.2 Builder’s plate RCD annex I, 2.2 A2.5...

  • Page 10: Definitions

    Yamarin Cross 57 Bow Rider 10 (51) 2 Definitions The warnings and cautions in this manual are defined as follows: Denotes an extreme intrinsic hazard that will result in a high probability DANGER! of death or permanent injury if proper precautions are not taken.

  • Page 11: Training

    Yamarin Cross 57 Bow Rider 11 (51) Training No one is a born sailor. There is plenty of boating literature available. Navigation courses are arranged by local yacht clubs or national boating associations where you can gain basic skills. However, please remember that you only become confident in boat handling, navigation,...

  • Page 12: Characteristics And Use Of Your Boat

    Yamarin Cross 57 Bow Rider 12 (51) Characteristics and use of your boat General The owner’s manual is not meant to be a complete service or repair manual; it simply guides the user to use his/her boat in a proper way.
  • Page 13 Yamarin Cross 57 Bow Rider 13 (51) Model YAMARIN CROSS 57 Bow Rider Design category Overall length (swim 5.66 m ladder not included) Width 2.17 m Weight without engine, c. 680 kg fluids and equipment Weight on trailer with c. 996 kg largest recommended Includes the boat (c.
  • Page 14 Yamarin Cross 57 Bow Rider 14 (51) Image: Boat’s water line. Water line: - at stern (A) 95 mm up from chine - at bow (B) 395 mm down from chine along the bow NOTE! Water line dimensions represent the upper limit for...

  • Page 15: Maximum Recommended Number Of Passengers

    Yamarin Cross 57 Bow Rider 15 (51) Maximum recommended number of passengers The maximum recommended number of passengers on board this boat is 6 persons. WARNING! Do not exceed the maximum recommended number of passengers. Regardless of the number of passengers, the total weight of people and equipment must never exceed the maximum recommended load (please refer to ‘Loading’).
  • Page 16 Yamarin Cross 57 Bow Rider 16 (51) Image: Seats on the boat.
  • Page 17 Yamarin Cross 57 Bow Rider 17 (51) NOTE! If you load the boat from stern to bow, you will have better fuel economy.

  • Page 18: Loading

    Yamarin Cross 57 Bow Rider 18 (51) Loading The boat’s maximum permitted load is 530 kg. This load includes the following weights: a) the total weight of passengers, 450 kg (the default weight of an adult is assumed to be 75 kg and that of a child 37.5 kg);...
  • Page 19 Yamarin Cross 57 Bow Rider 19 (51) 1. Hand-operated bilge pump 2. Rainwater drainage valve Image: Boat drainage system. The owner of the boat is responsible for ensuring that there is at least one bailer or bucket on the boat and that it has been secured.

  • Page 20: Stability And Buoyancy

    Yamarin Cross 57 Bow Rider 20 (51) NOTE! Make sure that water can flow unobstructed through the drainpipe. Debris such as autumn leaves may obstruct the water flow, which can cause the boat to fill with water and sink. The bilge pump system does not work in conditions below 0°C.

  • Page 21: Fire Protection

    Yamarin Cross 57 Bow Rider 21 (51) Do not stow any loose items under the aft seat that could prevent fuel flow to the engine if they shift. This is particularly important for items that may press against hoses or the fuel filter.
  • Page 22 Yamarin Cross 57 Bow Rider 22 (51) Remember: never hinder access to safety equipment, for instance the switches to the electric system; never hinder access to fire extinguishers located in a box; never make alterations to any of the boat’s systems (especially the electricity or the fuel systems) or allow an unqualified person to make alterations to any of the boat’s...

  • Page 23: Main Power Switch And Fuses

    Yamarin Cross 57 Bow Rider 23 (51) Main power switch and fuses Electric circuit fuses are located under the main power switch. Do not change the fuse amperages or install any components that exceed the nominal amperage of the circuit in the electric system.

  • Page 24: Operation

    Yamarin Cross 57 Bow Rider 24 (51) NOTE! Never cut the power from the main power switch while the engine is running, as this may cause damage to the engine’s electrical system. NOTE! Never install electric equipment on the boat with the power switched on.

  • Page 25: Gearshift And Throttle

    Yamarin Cross 57 Bow Rider 25 (51) steer the boat with that arm, because the emergency switch line may get caught on the wheel in sharp turns. NOTE! The engine will not start if the emergency switch is not attached to the switch on the remote control.
  • Page 26 Yamarin Cross 57 Bow Rider 26 (51) WARNING! Waves reduce manoeuvrability and make the boat heel. Accordingly, reduce speed when encountering heavier seas.

  • Page 27: Starting The Engine

    Yamarin Cross 57 Bow Rider 27 (51) 5.9.5 Starting the engine 1. Switch the power on using the main power switch. 2. Lower the engine to the driving position by pressing the Power Trim button on the gear/throttle handle. 3. Check that the gear/throttle handle is in the neutral position and that the emergency switch is attached to the bottom of the remote control.

  • Page 28: Approaching And Leaving The Dock

    Yamarin Cross 57 Bow Rider 28 (51) When running at low speed, a planing boat’s directional stability is poorer than at higher speeds. So be careful in narrow passages and, particularly, when meeting other boats. You must learn the rules of traffic on sea lanes and follow the international regulations on how to avoid collisions at sea, COLREG.

  • Page 29: Using The Canopy

    Yamarin Cross 57 Bow Rider 29 (51) departing easier, as the wind or current will push the bow out from the dock. The easiest way to depart is to first push the stern as far away from the dock as possible, and then slowly reverse away from the dock into open water.

  • Page 30: Proper Use - Other Recommendations And Guidelines

    Yamarin Cross 57 Bow Rider 30 (51) 5.10 Proper use – other recommendations and guidelines 5.10.1 Man overboard It is always a serious situation when someone falls overboard. Rescue procedures should be practised in advance during good weather, because it is too late for practice when someone has actually fallen into the water.

  • Page 31: Anchoring And Mooring The Boat

    Yamarin Cross 57 Bow Rider 31 (51) 5.10.4 Anchoring and mooring the boat Always moor your boat carefully, even in sheltered places, because conditions can change rapidly. Mooring lines should be equipped with absorbers to dampen any jolts. Please refer to the section on Towing for the location of bollards.

  • Page 32: Trailer Transport

    Yamarin Cross 57 Bow Rider 32 (51) Image: Attaching the towline to the bollards. WARNING! When towing, the towline is under high tension. If it should break, the end that snaps off may lash back fast enough to cause serious injury or death.

  • Page 33: Docking

    Yamarin Cross 57 Bow Rider 33 (51) Image: Attaching the boat to the trailer. Tie the boat properly before beginning transport. The sling ropes at the bow should be directed down and back, and the sling ropes at stern should be directed down and front. Do not leave any loose equipment or extra load on the boat when it is being transported.

  • Page 34: Servicing And Maintenance

    Yamarin Cross 57 Bow Rider 34 (51) transom, to support the added weight of the engine. Storage cradle dimensions are shown in the picture below. Image: Storage cradle dimensions. Only use reputable lifting companies or boat yards with sufficient lifting capacity. In addition to the boat’s tare weight (please refer to the technical specification), also take into consideration accessories and other possible loads in the boat.
  • Page 35 Yamarin Cross 57 Bow Rider 35 (51) Have your engine serviced according to the instructions in the manual.

  • Page 36: Washing And Waxing The Boat

    Yamarin Cross 57 Bow Rider 36 (51) Washing and waxing the boat Cleaning fibreglass surfaces Normally it is sufficient to just wash and wax the deck. Special boat cleaning agents are most suitable for the purpose. Do not use strong solvents; they can cause glossy surfaces to fade.

  • Page 37: Care Instructions For Seat Cushions

    Yamarin Cross 57 Bow Rider 37 (51) Protecting the aluminium hull When the aluminium hull is completely clean and dry, it can be protected against oxidation. Spray Star brite Aluminum Polish on the surface to be treated and spread it out with a soft, lint-free cloth.

  • Page 38: Care Instructions For The Canopy (Optional Accessory)

    Yamarin Cross 57 Bow Rider 38 (51) NOTE! Wet cushions should not be placed in storage, because they gather mould easily. The press studs of the seat cushions should be sprayed with silicon spray every now and then, otherwise they may become so tight that the fabric will tear when trying to open them.

  • Page 39: Care Instructions For The Remote Control

    Yamarin Cross 57 Bow Rider 39 (51) 6.6 Care instructions for the remote control Normally, the remote control needs no other maintenance apart from greasing and calibration during winter servicing. If the remote control becomes stiff for any reason, it needs to be serviced immediately.

  • Page 40: Winter Storage

    Yamarin Cross 57 Bow Rider 40 (51) WARNING! Be careful when handling the hardening agent. If the hardening agent vessel/bottle leaks, or some agent drops onto a dirty floor or rag, there is a very high risk of the surface catching fire. Do not throw into the rubbish bin any rags or vessels containing topcoat / hardening agent mixture.

  • Page 41: Measures Before Launching The Boat

    Yamarin Cross 57 Bow Rider 41 (51) the ropes in fresh water. Replace any worn ropes. Leave bushing valves open. Remove the drain plug for the winter. Electronic instruments are best protected against oxidation and theft by detaching them and removing them to a dry indoor environment for the winter.

  • Page 42: Lay-Out

    Yamarin Cross 57 Bow Rider 42 (51) When the boat has been launched you should open all hull bushings and check to ensure that there are no leaking hoses or connectors. The locations of bushings (through fittings) are shown in section 5. Bring your safety equipment back on board before setting out.
  • Page 43 Yamarin Cross 57 Bow Rider 43 (51) 1. Rainwater drainage valve 6. Main power switch 2. Hand-operated bilge pump 7. Fuse panel 3. Fire extinguisher 8. Fuel refill 4. Fuel filter 9. Canopy housing 5. Battery (not standard equipment) Image: General lay-out.

  • Page 44: Fuel System

    Yamarin Cross 57 Bow Rider 44 (51) Fuel system The boat has a built-in fuel tank. A fuel filter is installed in the fuel line. The filter must be changed at least once a year. When a new or removed filter has been mounted, the fuel line must be filled with a ball pump before starting the engine.

  • Page 45: Steering System

    If you replace any component in the steering system, please note that all components must conform to the ISO 10592 standard and carry the CE mark. Electrical system The Yamarin Cross 57 BR electrical system contains the following main components: 1. Wire harness 2. Main power switch 3. Windshield wiper 4.

  • Page 46: Wiring Diagram

    Yamarin Cross 57 Bow Rider 46 (51) Wiring diagram...
  • Page 47 Yamarin Cross 57 Bow Rider 47 (51)
  • Page 48 Yamarin Cross 57 Bow Rider 48 (51)
  • Page 49 Yamarin Cross 57 Bow Rider 49 (51)
  • Page 50 Yamarin Cross 57 Bow Rider 50 (51)
  • Page 51 Yamarin Cross 57 Bow Rider 51 (51) Image: Wiring diagram...

This manual is also suitable for:

Cross 75Cross 46 side consoleCross 54 bow rider

Table of Contents