Page 2
Yamarin 65 Day Cruiser 2 (40) FOREWORD Congratulations on choosing a Yamarin 65 DC! We are delighted to welcome you as a Yamarin owner. The intention of this manual is to help you to operate your craft safely, with maximum enjoyment.
Yamarin 65 Day Cruiser 3 (40) Table of contents 1 General 1.1 Declaration of conformity 2 Definitions 3 Warranty 4 Before use 4.1 Registration 4.2 Insurance 4.3 Training 5 Characteristics and use of your boat 5.1 General 5.2 Basic data 5.3 Maximum recommended number of passengers...
Page 4
Yamarin 65 Day Cruiser 4 (40) 6.2 Care instructions for seat cushions 6.3 Care instructions for the canopy 6.4 Care instructions for the windshield 6.5 Care instructions for the stainless steel components 6.6 Care instructions for the remote control 6.7 Care instructions for the steering system 6.8 Care instructions for the electrical components...
Page 5
Yamarin 65 Day Cruiser 5 (40) BEFORE YOU SET OFF Familiarise yourself with this owner’s manual. Always check at least the following items before leaving: Weather conditions and forecast − − − − Take the wind, waves and visibility into account. Are the design category, size and...
Yamarin 65 Day Cruiser 6 (40) General The owner’s manual will help you to become familiarised with the properties and features of your new boat, as well as with its care and maintenance. Separate manuals for installed equipment are attached and are referred to in many sections of the owner’s manual. You can, of course, complement this owner’s manual by adding the manuals of devices which are...
Page 7
Yamarin 65 Day Cruiser 7 (40) DECLARATION OF CONFORMITY Recreational Craft Directive 94/25/EY and 2003/44/EY Manufacturer: Selio Boats Oy and Fenix Marin Oy Module used: B, EC Type Examination ----------------------------------------------------------------------------------------------------------------- THIS DECLARATION IS PREPARED BY Prepared by: Konekesko Oy Marine...
Page 8
Yamarin 65 Day Cruiser 8 (40) Type of craft: Deck: 01 sailboat 01 decked 02 inflatable 02 partly decked 03 other: motorboat 03 open: Type of hull: Propulsion: 01 monohull 01 sails 02 multihull 02 petrol engine 03 other: 03 diesel engine...
Page 9
Yamarin 65 Day Cruiser 9 (40) Essential safety requirements ISO-standards used Other normative document used General requirements (2) Basic information EN ISO 8666:2002 Hull Identification Number – CIN (2.1) ISO 10087:1996 / A1:2000 Builder’s Plate (2.2) RCD annex I, 2.2 Protection from falling overboard…...
Yamarin 65 Day Cruiser 10 (40) Definitions The warnings and cautions in this manual are defined as following: DANGER! Denotes an extreme intrinsic hazard exists which would result in high probability of death or irreparable injury if proper precautions are not taken.
Basic data Recreational crafts can be constructed according to 4 categories (A, B, C and D) according to the recreational craft directive 94/25/EC. Yamarin 65 DC is constructed according to category C. Below you will find information on what each category means: Category A: The boat is built for conditions where the wind can exceed 8 Beaufort (approx.
Page 12
Yamarin 65 Day Cruiser 12 (40) Note: Significant wave height is a term used when planning to build a boat. The significant wave height is the mean height of the highest one third of the waves, which approximately corresponds to the wave height estimated by an experienced observer.
Page 13
Yamarin 65 Day Cruiser 13 (40) Technical specifications Model YAMARIN 65 Day Cruiser Design category Overall length (swim 6,35 m ladder not included) Width 2,46 m Weight without Approx. 1150 kg engine, fluids and equipment Weight on trailer Approx. 1600 kg with biggest Includes the boat (approx.
Water line dimension represents the upper limit for antifouling paint, not the actual water line. Maximum recommended number of passengers The maximum recommended number of passengers on board Yamarin 65 DC is 7 persons. WARNING! Do not exceed the maximum recommended number of passengers.
If you load the boat from stern to bow, you will have better fuel economy. Loading The maximum permitted load for the Yamarin 65 DC is 700 kg. This load includes the following weights: a) the total weight of passengers 525 kg (the default weight of an adult is assumed to be...
16 (40) Engine and propeller The maximum recommended engine power for the Yamarin 65 DC is 225 hp (166 kW). The construction of the boat is not designed to bear more power than 225 hp. The manoeuvrability of the boat can be very dangerous if the boat has bigger than 225 hp engine. The warranty is not valid if boat is used with more power than 225 hp.
Yamarin 65 Day Cruiser 17 (40) The owner of the boat is responsible for ensuring that there is at least one baler or bucket on the boat and that it has been secured. WARNING! The bilge pump system is not intended to cope with a leakage caused by running aground or other equivalent damage.
In the event that the fire extinguisher is replaced the capacity of the new one should be the equivalent of the old one. Location of fire extinguisher in Yamarin 65 DC (1)
(225 hp). Do not use the boat with bigger engine power than marked on the builder’s plate. 5.9.1 Controls You will quickly learn how to control your Yamarin 65 DC, but constantly changing weather conditions, like wind and waves, will always present new challenges for the driver. The...
Yamarin 65 Day Cruiser 20 (40) remote control combines the functions of throttle, forward and reverse gears, and the adjusting of the engine trim angle. The boat has a hydraulic steering system. 5.9.2 Emergency switch The emergency switch is a device with one end attached to the switch under the remote control and the other end to, for instance, your life vest.
Yamarin 65 Day Cruiser 21 (40) WARNING! Do not drive the boat at high speeds with the engine trimmed up (bow up) as there is a risk of sudden heeling when the propeller hits the water again after a flight in heavy waves. Likewise do not...
Yamarin 65 Day Cruiser 22 (40) waves (also consult the passengers about a comfortable speed) your own bow wake (greatest at planing speed, least at speeds under 5 knots) visibility (islands, fog, rain, driving against the sun) familiarity with the route (sufficient time for navigation) the width of the route (other traffic, noise and wash on shore) make sure, that there is always sufficient distance to avoid collision.
WARNING! Yamarin 65 DC is a fast boat. It does not stop instantly when at planing speed. Slow down in plenty of time before anchoring, beaching or docking. Learn to estimate the distance the boat needs before it stops.
Yamarin 65 Day Cruiser 24 (40) 5.10 Proper use – other recommendations and guidelines 5.10.1 Man-overboard It is always a serious situation when someone falls overboard. Rescue procedures should be practised in advance when the weather is good, because when someone has fallen overboard, there is no time for practising.
Yamarin 65 Day Cruiser 25 (40) abrasion, use fenders that are large enough. The location of the bollards is illustrated on the image in the section on towing. The hook located at the bow of the boat is for fastening the boat to trailer. Hook at the deck is for locking the boat for example to the dock.
Yamarin 65 Day Cruiser 26 (40) WARNING! When towing, the towline is under high tension. If it breaks, the speed of the end that has snapped off may rebound and cause serious injury or death. Always use a thick enough rope and do not get in the way of the rope extension.
Yamarin 65 Day Cruiser 27 (40) Yamarin 65 DC fastening on trailer: Tie the boat properly before starting the transport. Fastening belts located at the bow should be directed "down-back" and fastening belts located at rear should be directed "down-front".
Yamarin 65 Day Cruiser 28 (40) Storage cradle dimensions: Only use reputable lifting companies or boat yards with sufficient lifting capacity. In addition to the boat's own weight (please refer to technical specification), also take into consideration the accessories and other possible loads on the boat.
Yamarin 65 Day Cruiser 29 (40) Useful tips: Washing the boat will be easier when it is done immediately after getting the boat off the water. Useful tips: When the boat has been washed using tap water, a thin chalk-like layer of lime and minerals will remain on the boat’s surface after it...
Yamarin 65 Day Cruiser 30 (40) Useful tips: When wiping the boat's windshield dry after cleaning avoid using circular motions. This can leave circular smudges on the windshield that become visible in sunlight impeding visibility. Wipe off any streaks with dry newspaper or cotton cloth first using horizontal motions and then vertical motions.
Yamarin 65 Day Cruiser 31 (40) need be removed from the surface as teak, being a dense, oily wood, does not absorb dirt deeply. The teak batten and pegs should be around 8 mm and 5 mm thick respectively. Removing up to half or even one millimetre will not affect the durability of the teak deck, and will give it a brand new finish.
Always cover your boat so that water or snow cannot gather inside. Always make sure, however, that there is adequate ventilation. As an optional extra there is a winter storage protector for your Yamarin 65 DC. NOTE! To avoid abrasion make sure that covering or ropes do not touch the aluminium hull.
Page 33
Yamarin 65 Day Cruiser 33 (40) on aluminium parts and remember to follow the paint manufacturer’s instructions. Useful tips: Do not throw away a used paint brush. A dried and hardened paint brush that has been used for antifouling paint can be reused if you first soak it for a couple of hours in a mix of 2 litres of hot water, 100 ml of vinegar, and 50 ml of baking powder.
Yamarin 65 Day Cruiser 34 (40) Lay-out 8.1 General lay-out 1. Fuel refill 6. Canopy storage compartment 2. Hand pump 7. Placement for cool box 3. Remote control 8. Placement for trim switch 4. Instrument panel 9. Placement for anchor roll 5.
6. Hand pump thru fitting Fuel system Yamarin 65 DC is equipped with a built-in-fuel tank. There is a fuel filter, which also serves as a transparent water separator. The filter must be changed at least once a year. When a new or removed filter has been mounted, the fuel line must be filled with a ball pump before starting the engine.
- symbol. Steering system Yamarin 65 DC is equipped with a hydraulic steering system as standard. One of the features of the hydraulic steering system is that the position of the steering wheel changes continuously. For this reason, the boat has a symmetrical steering wheel. The lengths of hydraulic hoses are 5.5 meters.
Yamarin 65 Day Cruiser 37 (40) Electrical system The electrical system installed in the Yamarin 65 DC includes the following main components: 1. BATTERY 2. WIRE HARNESS 3. MAIN SWITCH 4. FUSE PANEL 5. 3 PCS SWITCHES WITH AUTOMATIC FUSES 6.